Elucidation of Reaction Behaviors in Sonocatalytic Decolorization of Amaranth Dye in Water Using Zeolite Y Co-Incorporated with Fe and TiO<sub>2</sub> — Oak Academic Publishing
Research ArticleOpen AccessGoogle Scholar indexed
Elucidation of Reaction Behaviors in Sonocatalytic Decolorization of Amaranth Dye in Water Using Zeolite Y Co-Incorporated with Fe and TiO<sub>2</sub>
School of Chemical Engineering, Universiti Sains Malaysia, Penang, Malaysia
,
,
1 School of Chemical Engineering, Universiti Sains Malaysia, Penang, Malaysia
The Zeolite Y as a support was modified by the incorporating of Fe and TiO 2 in one single step using impregnation method. The synergistic effects between those components enhance the catalytic activity for the degradation of amaranth dye under ultrasonic irradiation with output power of 50 W and 40 kHz frequency. Different characterization techniques were used to elucidate the physical and chemical properties of the produced catalysts. The XRD results indicated that the type of titanium precursor significantly effects on the crystallinity of 0.4% Fe/15%TiO 2 -NaY catalyst. The AFM results detected that the TiO 2 formed a layer covered the surface of zeolite while Fe clusters were located close to TiO 2 . The influence of reaction parameters such as TiO 2 and Fe content, pH values, amount of hydrogen peroxide used, catalyst loading and the initial dye concentration were investigated for the decolorization efficiency of amaranth. The maximum decolorization efficiency for 0.4%Fe/15%TiO 2 -NaY was 100% after 120 min of reaction time with an initial dye concentration of 30 mg/L, 2 g/L of catalyst loading, natural pH about 5.5 and 0.65 mM H 2 O 2 .
KeywordsDye DegradationImpregnation MethodIncorporation of Metals
H. Wang, Y. Shen, C. Shen, Y. Wen and H. Li, “Enhanced Adsorption of Dye on Magnetic Fe 3 O 4 via HCl-Assisted Sonication Pretreatment,” Desalination, Vol. 284, 2012, pp. 122-127. doi:10.1016/j.desal.2011.08.045
M. Huang, C. Xu, Z. Wu, Y. Huang, J. Lin and J. Wu, “Photocatalytic Discolorization of Methyl Orange Solution by Pt Modified TiO 2 Loaded on Natural Zeolite,” Dyes and Pigments, Vol. 77, No. 2, 2008, pp. 327-334. doi:10.1016/j.dyepig.2007.01.026
S. S. Rayalu, N. Dubey, R. V. Chatti, M. V. Joshi, N. K. Labhsetwar and S. Devotta, “Effect of Heteropolyacid and Its Route of Incorporation on the Photocatalytic Properties of Zeolite-Based Materials,” Current Science, Vol. 93, No. 10, 2007, pp. 1376-1382.
A. N. Soon and B. H. Hameed, “Heterogeneous Catalytic Treatment of Synthetic Dyes in Aqueous Media Using Fenton and Photo-Assisted Fenton Process,” Desalination, Vol. 269, No. 1-3, 2011, pp. 1-16. doi:10.1016/j.desal.2010.11.002
A. H. Alwash, A. Z. Abdullah and N. Ismail, “Zeolite Y Encapsulated with Fe-TiO 2 for Ultrasound-Assisted Degradation of Amaranth Dye in Water,” Journal of Hazardous Materials, Vol. 233-234, 2012, pp. 184-193. doi:10.1016/j.jhazmat.2012.07.021
Y. L. Pang, S. Bhatia and A. Z. Abdullah, “Process Behavior of TiO 2 Nanotube-Enhanced Sonocatalytic Degradation of Rhodamine B in Aqueous Solution,” Separation and Purification Technology, Vol. 77, No. 3, 2011, pp. 331-338. doi:10.1016/j.seppur.2010.12.023
R. J. Tayade, R. G. Kulkarni and R. V. Jasra, “Enhanced Photocatalytic Activity of TiO 2 -Coated NaY and HY Zeolites for the Degradation of Methylene Blue in Water,” Industrial and Engineering Chemistry Research, Vol. 46, No. 2, 2007, pp. 369-376. doi:10.1021/ie060641o
X. Li, B. Shen and C. Xu, “Interaction of Titanium and Iron Oxide with ZSM-5 to Tune the Catalytic Cracking of Hydrocarbons,” Applied Catalysis A: General, Vol. 375, No. 2, 2010, pp. 222-229. doi:10.1016/j.apcata.2009.12.033
P. Castano, B. Pawelec, J. L. G. Fierro, J. M. Arandes and J. Bilbao, “Aromatics Reduction of Pyrolysis Gasoline (PyGas) over HY-Supported Transition Metal Catalysts,” Applied Catalysis A: General, Vol. 315, 2006, pp. 101-113. doi:10.1016/j.apcata.2006.09.009
C. Wang, H. Shi and Y. Li, “Synthesis and Characteristics of Natural Zeolite Supported Fe 3+ -TiO 2 Photocatalysts,” Applied Surface Science, Vol. 257, No. 15, 2011, pp. 6873-6877. doi:10.1016/j.apsusc.2011.03.021
C. C. Wang, C. K. Lee, M. D. Lyu and L. C. Juang, “Photocatalytic Degradation of C.I. Basic Violet 10 Using TiO 2 Catalysts Supported by Y Zeolite: An Investigation of the Effects of Operational Parameters,” Dyes and Pigments, Vol. 76, No. 3, 2008, pp. 817-824. doi:10.1016/j.dyepig.2007.02.004
A. Z. Abdullah and P. Y. Ling, “Heat Treatment Effects on the Characteristics and Sonocatalytic Performance of TiO 2 in the Degradation of organic Dyes in Aqueous Solution,” Journal of Hazardous Materials, Vol. 173, No. 1-3, 2010, pp. 159-167. doi:10.1016/j.jhazmat.2009.08.060
H. Hassan and B. H. Hameed, “Oxidative Decolorization of Acid Red 1 Solutions by Fe-Zeolite Y Type Catalyst,” Desalination, Vol. 276, No. 1-3, 2011, pp. 45-52. doi:10.1016/j.desal.2011.03.018
G. Li, “FT-IR Studies of Zeolite Materials: Characterization and Environmental Applications,” The University of Iowa’s Institutional Repository, 2005.
C. Li and Z. Wu, “Microporous Materials Characterized by Vibrational Spectroscopies,” In: S. M. Auerbach, K. A. Carrado and P. K. Dutta, Eds., Handbook of Zeolite Science and Technology, CRC Press, Boca Raton 2003, pp. 423-514. doi:10.1201/9780203911167.ch11
M. Nikazar, K. Gholivand and K. Mahanpoor, “Photocatalytic Degradation of Azo Dye Acid Red 114 in Water with TiO 2 Supported on Clinoptilolite as a Catalyst,” Desalination, Vol. 219, No. 1, 2008, pp. 293-300. doi:10.1016/j.desal.2007.02.035
H. G. Karge, “Characterization by Infrared Spectroscopy,” Microporous Mesoporous Materals, Vol. 22, No. 4-6, 1998, pp. 547-549. doi:10.1016/S1387-1811(98)80021-8
N. N. Mahamuni and A. B. Pandit, “Effect of Additives on Ultrasonic Degradation of Phenol,” Ultrasonic Sonochemistry, Vol. 13, No. 2, 2006, pp. 165-174. doi:10.1016/j.ultsonch.2005.01.004
F. A. Q. Ortíz, J. T.Valenzuela and C. A. R. Reyes, “Zeolitisation of Neogene Sedimentary and Pyroclastic Rocks Exposed in Paipa (Boyacá), in the Colombian Andes: Simulating Their Natural Formation Conditions,” Earth Sciences Research Journal, Vol. 15, No. 2, 2011, pp. 89-100.
H. Faghihian and A. Bahranifard, “Application of TiO 2 -Zeolite as Photocatalyst for Photodegradation of Some Organic Pollutants,” Iranian Journal of Catalysis, Vol. 1, No. 1, 2011, pp. 45-50.
C. Bajamundi, M. Dalida, K. Wantala, P. Khemthong and N. Grisdanurak, “Effect of Fe 3+ Doping on the Performance of TiO 2 Mechanocoated Alumina Bead Photocatalysts,” Korean Journal of Chemical Engineering, Vol. 28, No. 8, 2011, pp. 1688-1692. doi:10.1007/s11814-011-0031-7
J. Herney-Ramirez, M. A. Vicente and L. M. Madeira, “Heterogeneous Photo-Fenton Oxidation with Pillared Clay-Based Catalysts for Wastewater Treatment: A Review,” Applied Catalysis B: Environmental, Vol. 98, No. 1-2, 2010, pp. 10-26. doi:10.1016/j.apcatb.2010.05.004
J. Wang, W. Sun, Z. Zhang, Z. Jiang, X. Wang, R. Xu, R. Li and X. Zhang, “Preparation of Fe-Doped Mixed Crystal TiO 2 Catalyst and Investigation of Its Sonocatalytic Activity during Degradation of Azo Fuchsine under Ultrasonic Irradiation,” Journal of Colloid and Interface Science, Vol. 320, No. 1, 2008, pp. 202-209. doi:10.1016/j.jcis.2007.12.013
X. Zhong, L. Xiang, S. Royer, S. Valange, J. Barrault and H. Zhang, “Degradation of C.I. Acid Orange 7 by Heterogeneous Fenton Oxidation in Combination with Ultrasonic Irradiation,” Journal of Chemical Technology & Biotechnology, Vol. 86, No. 7, 2011, pp. 970-977.
M. Neamtu, C. Zaharia, C. Catrinescu, A. Yediler, M. Macoveanu and A. Kettrup, “Fe-Exchanged Y Zeolite as Catalyst for Wet Peroxide Oxidation of Reactive Azo Dye Procion Marine H-EXL,” Applied Catalysis B: Environmental, Vol. 48, No. 4, 2004, pp. 287-294. doi:10.1016/j.apcatb.2003.11.005
R. Aravindhan, N. N. Fathima, J. R. Rao and B. U. Nair, “Wet Oxidation of Acid Brown Dye by Hydrogen Peroxide Using Heterogeneous Catalyst Mn-Salen-Y Zeolite: A Potential Catalyst,” Journal of Hazardous Materials, Vol. 138, No. 1, 2006, pp. 152-159. doi:10.1016/j.jhazmat.2006.05.052
Y. L. Pang, A. Z. Abdullah and S. Bhatia, “Review on Sonochemical Methods in the Presence of Catalysts and Chemical Additives for Treatment of Organic Pollutants in Wastewater,” Desalination, Vol. 277, No. 1-3, 2011, pp. 1-14. doi:10.1016/j.desal.2011.04.049
M. B. Kasiri, H. Aleboyeh and A. Aleboyeh, “Degradation of Acid Blue 74 Using Fe-ZSM5 Zeolite as a Heterogeneous Photo-Fenton Catalyst,” Applied Catalysis B: Environmental, Vol. 84, No. 1-2, 2008, pp. 9-15. doi:10.1016/j.apcatb.2008.02.024
N. A. Jamalluddin and A. Z. Abdullah, “Reactive Dye Degradation by Combined Fe(III)/TiO 2 Catalyst and Ultrasonic Irradiation: Effect of Fe(III) Loading and Calcination Temperature,” Ultrasonic Sonochemistry, Vol. 18, No. 2, 2011, pp. 669-678. doi:10.1016/j.ultsonch.2010.09.004
N. A. Jamalluddin and Z. A. Ahmad, “Effect of pH and Catalyst Dosage on the Leaching of Fe from Fe(III) Doped Zeolite Y Used for Sonocatalytic Degradation of Acid Red B,” Research Journal of Chemistry and Environment, Vol. 15, No. 2, 2011, pp. 860-865.