Low Temperature Glycerolysis as a High FFA Pre-Treatment Method for Biodiesel Production
- 1
- 2
- 3
- 4
- 5
Abstract
A novel low temperature glycerolysis process for lowering free fatty acid (FFA) in crude jatropha oil for alkali catalyzed transesterification has been developed. The response surface methodology (RSM) based on central composite design was used to model and optimize the glycerolysis efficiency under three reaction variables namely; reaction time, temperature and glycerol to oil mass ratio. The optimum conditions for highest glycerolysis efficiency of 98.67% were found to be temperature of 65℃ , reaction time of 73 minutes and 2.24 g/g glycerol to oil mass ratio. These conditions lower the high free fatty acid of crude jatropha oil from 4.54% to 0.0654% which is below 3% recommended for alkali catalyzed transesterification. The pre-treated crude jatropha oil was then transesterified by using homogeneous base transesterification resulting to a conversion of 97.87%. The fuel properties of jatropha biodiesel obtained were found to be comparable to those of ASTM D6751 and EN 14214 standards. The process can also utilize the crude glycerol from the transesterification reaction, hence lowering the cost of biodiesel. The glycerolysis is easier implemented than acid esterification thereby avoiding the need for neutralization and alcohol removal step.
- A. B. Chhetri, M. S. Tango, S. M. Budge, K. C. Watts, and M. R. Islam, “Non-Edible Plant Oils as New Sources for Biodiesel Production,” International Journal of Molecular Sciences, Vol. 9, No. 2, 2008, pp. 169-180. http://dx.doi.org/10.3390/ijms9020169
- T. Krawczyk, “Biodiesel-Alternative Fuel Makes Inroads but Hurdles Remain,” Inform, Vol. 7, 1996, pp. 801-815.
- Z. Helwani, M. R. Othman, N. Aziz, W. J. N. Fernando, and J. Kim, “Technologies for Production of Biodiesel Focusing on Green Catalytic Techniques: A Review,” Fuel Processing Technology, Vol. 90, No. 12, 2009, pp. 1502-1514.
- D. Bacovsky, W. Korbitz, M. Mittelbach and M. Worgetter, “Biodiesel Production: Technologies and European Providers,” Report T39-B6, 2007.
- Y. Zhang, M. A. Dube, D. D. McLean and M. Kates, “Biodiesel Production from Waste Cooking Oil: 1. Process Design and Technological Assessment,” Bioresource Technology, Vol. 89, No. 1, 2003, pp. 1-16. http://dx.doi.org/10.1016/S0960-8524(03)00040-3
- M. A. Hanna and F. Ma, “Biodiesel Production: A Review,” Bioresource Technology, Vol. 70, 1999, pp. 1-15.
- G. Knothe, J. Van Gerpen and J. Krahl, “Basics of the Transesterification Reaction,” In: The Biodiesel Hand-book, AOCS Press, Champaign, 2005, pp. 26-41.
- M. Dorado, E. Ballesteros, J. De Almeida, C. Schellert, H. Lohrlein and R. Krause, “An Alkali-Catalyzed Transesterification Process for High Free Fatty Acid Waste Oils,” Transactions of the ASAE, Vol. 45, 2002, pp. 525-529.
- A. J. C. Anderson, “Refining of Oils and Fats for Edible Purposes,” 2nd Edition, Pergamon Press, London, 1962, pp. 92-103.
- P. Felizardo, J. Machado, D. Vergueiro, M. J. N. Correia, J. P. Gomes and J. M. Bordado, “Study on the Glycerolysis Reaction of High Free Fatty Acid Oils for Use as Biodiesel Feedstock,” Fuel Processing Technology, Vol. 92, No. 6, 2011, pp. 1225-1229. http://dx.doi.org/10.1016/j.fuproc.2011.01.020
- N. O. V. Sonntag, “Glycerolysis of Fats and Methyl Esters—Status, Review and Critique,” Journal of the American Oil Chemists’ Society, Vol. 59, 1982, pp. 795-802.
- H. Noureddini, D. Harkey and M. Gutsman, “A Continuous Process for the Glycerolysis of Soybean Oil,” Journal of the American Oil Chemists’ Society, Vol. 81, 2004, pp. 203-207.
- A. Khuri and J. A. Comell, “Response Surfaces Design and Analysis,” Marcel Dekker, New York, 1987.