Case Study of Biodiesel-Diesel Blends as a Fuel in Marine Environment
- 1
- 2
- 3
- 4
- 5
- 6
- 7
- 8
Abstract
Formation of excessive sludge and fuel filter clogging were experienced in using biodiesel blends under marine environment. In this study, a field test was conducted in a marine ferry boat fueled by canola-based biodiesel blends. The sludge materials collected in the fuel purifier were characterized using inductively coupled plasma (ICP), pyrolysis-GC/MS (Py-GC/MS), thermogravimetric analysis (TGA), and Karl-Fischer titration. It was found that the sludge materials consisted of four distinctive fractions: organic materials derived from diesel and canola biodiesel (major fraction), ash (11-14% w/w), water (~17% w/w), and bacteria. The active bacteria were present in the sludge samples. It was suggested that bacterial contamination was one of the major factors in contribution to the sludge formation.
- U. S. Department of Energy, “Biodiesel Handling and Use Guideline,” 2nd Edition, 2006. http://www.osti.gov/bridge
- R. O. Dunn, “Cold Weather Properties and Performance of Biodiesel,” In: G. Knothe, J. Krahl and J. Van Gerpen Eds., The Biodiesel Handbook, AOCS Press, Urbana, 2005, pp. 83-121. doi:10.1201/9781439822357.ch6.3
- D. S. Shrestha, J. Van Gerpen and J. Thompson, “Effectiveness of Cold Flow Additives on Various Biodiesel, Diesel and their Blends,” Transactions of ASABE, Vol. 51, No. 14, 2008, pp. 1365-1370.
- H. Tang, C. Rhet and C. De Guzman, “Formation of Insolubles in Palm Oil-, Yellow Grease-, and Soybean Oil-Based Biodiesel Blends after Cold Soaking at 4?C,” Journal of the American Oil Chemists’ Society, Vol. 85, No. 12, 2008, pp. 1131-1182.
- H. Tang, S. O. Salley and K. Y. S. Ng, “Fuel Properties and Precipitate Formation at Low Temperature in Soy-, Cottonseed-, and Poultry Fat-Based Biodiesel Blends,” Fuel, Vol. 87, No. 13-14, 2008, pp. 3006-3017. doi:10.1016/j.fuel.2008.04.030
- S. Chen, “Report of Findings from 2004 WSF Biodiesel Pilot Test,” Pullman, 2007. http://www.wsdot.wa.gov/NR/rdonlyres/84094DDC-194E-4FB3-8D28-6916F6E5E058/0/B_Appendix_2004_Pilot_Test_15April09.pdf
- Y. Chao, N. Liu, T. Zhang and S. Chen, “Isolation and Characterization of Bacteria from Engine Sludge Generated from Biodiesel-Diesel Blends,” Fuel, Vol. 89, No. 11, 2010, pp. 3358-3364. doi:10.1016/j.fuel.2010.05.041
- S. Apirattananusorn, S. Tongta, S. W. Cui and Q. Wang, “Chemical, Molecular, and Structural Characterization of Alkali Extractable Nonstarch Polysaccharides from Job’s Tears,” Journal of Agricultural and Food Chemistry, Vol. 56, No. 18, 2008, pp. 8549-8557. doi:10.1021/jf801231y
- J. Dweck, and C. M. S. Sampaio, “Analysis of the Thermal De-composition of Commercial Vegetable Oils in Air by Simultaneous TG/DTA,” Journal of Thermal Analysis and Calorimetry, Vol. 75, No. 2, 2004, pp. 385-391. doi:10.1023/B:JTAN.0000027124.96546.0f
- M. B. Dantas, M. M. Conceio, Jr., V. J. Fernandes, N. A. Santos, R. Rosenhaim, A. L. B. Marques, I. M. G. Santos and A. G. Souza, “Thermal and Kinetic Study of Corn Biodiesel Obtained by the Methanol and Ethanol Routes,” Journal of Thermal Analysis and Calorimetry, Vol. 87, No. 3, 2007, pp. 835-839. doi:10.1007/s10973-006-7780-2
- B. He, J. Thomp-son, D. Routt and J. Van Gerpen, “Moisture Absorption in Biodiesel and Its Petro-Diesel Blends,” Applied Engi-neering in Agriculture, Vol. 23, No. 1, 2007, pp. 71-76.