Base-transesterification process for biodiesel fuel production from spent frying oils
- 1 Karary University, Omdurman, Sudan
- 2 Industrial Research and Consultancy Centre, Khartoum North, Sudan
Abstract
The concept of converting recycled oils to clean biodiesel aims towards reducing the amount of waste oils to be treated and lowering the cost of biodiesel production. Samples of waste oils were prepared from Spent Frying oil collected from local hotels and restaurants in Khartoum, Sudan. Selected methods to achieve maximum yield of biodiesel using the waste feedstock were presented and compared. Some properties of the feedstock, such as free fatty acid content and moisture content, were measured and evaluated. Biodiesel yield recovery obtained, from Base- transesterification process about 92%. Pro duced Biodiesel specifications were also analyzed and discussed in Base-transesterification process. Kinematic viscosity of biodiesel was found to be 5.51 mm 2 ·s ?1 at 40?C, the flash point was 174.2?C and Cetane No of 48.19. Biodiesel was characterized by its physical and fuel properties according to ASTM and DIN V 51606 standards.
- Hideki, F., Akihiko, K. and Hideo, N. (2001) Biodiesel fuel production by transesterification of oils. University of Kobe, Kobe.
- Guo, Y., Leung, Y.C. and Koo, C.P. (2002) A clean biodiesel fuel produced from recycled oils and grease trap oils. Department of Mechanical Engineering, University of Hong Kong, Hong Kong.
- Zhang, Y., Dub, M.A., McLean, D.D. and Kates, M. (2003) Biodiesel production from waste cooking oil: 1. Process design and technological assessment. Department of Chemical Engineering, University of Ottawa, Ottawa.
- Dan, A., Derek, M. and Bill, M. and Larry, S. (2003) Industrial biodiesel plant design and engineering, practical experience. International Palm Oil Conference, Putrajaya, Malaysia, 24-28 August 2003, 10p.
- Marina, E., Antonio, S., Boyan, K. and Peder, J. (2002) Techno-economic analysis of biodiesel production in the EU, a short summary for decision-makers. Report EUR 20279 EN.
- Patel, M.K. (2002-2003) Biodiesel from rapeseed oil and used frying oil, in European Union.
- Zach, C. (2005) Alternative fuels as a solution. History of Alternative Fuel Development.
- Tao, B.Y. (2005) Biofuels for home heating oil. Department of Agricultural and Biological Engineering, University of Purdue, West Lafayette.
- Van Gerpen, J., Shanks, B. and Pruszko, R. (2004) Biodiesel production technology. Iowa State University, Ames.
- Naveen, K. (2006) Moving toward sustainable energy systems. University of Minnesota, Minneapolis.
- Lee, S., Speight, J.G. and Loyalka, S.K. (2007) Handbook of alternative fuel technologies. Taylor and Francis Group, LLC, Boca Raton.
- Erhan, S.Z. (2005) Industrial uses of vegetable oils. National Center for Agricultural Utilization Research, Agricultural Research Service, United States.
- Chakrit, T. (2009) Biodiesel technology over view. Prince of Songkla University, Songkhla, Thailand.
- Pornsiri, K. (2009) Feedstock with high free fatty acid (FFA). Annul International Training Course (Biodiesel Technology), PSU, Thailand.
- Chakrit, T. (2009) Biodiesel project, specialized research and development center for alternative energy from palm oil and oil crops. Faculty of Engineering, Prince of Songkla University, Songkhla, Thailand.