Investigation of Critical Characteristics of Mineral Oil with Activated Carbon
- 1 Department of Electrical and Electronics Engineering, Coimbatore Institute of Engineering and Technology, Coimbatore, India
- 2 Department of Electrical Engineering, Government College of Technology, Coimbatore, India
- 3 Department of Electrical and Electronics Engineering, Coimbatore Institute of Engineering and Technology, Coimbatore, India
Abstract
Fluid insulating medium is used for electrical insulation and provides a cooling medium in high voltage power transformers. Due to this reason, petroleum based mineral oil (transformer oil) is mostly used for a number of years which holds the benefit of cost effectiveness and good flow rate. This benefit leads to more requirements of oil that may cause oil scarcity in the near future. In order to overcome the scarcity in forthcoming years many research works focus on identifying the best approach for regeneration of oils. In this paper, activated carbon obtained from the agricultural waste is used which acts as the absorbent of impurities. Use of activated carbon is a perfect approach for regeneration of oils. Critical characteristics such as breakdown voltage, flash point, fire point and viscosity are measured for the pure and aged mineral oil with and without adding activated carbon. By this approach it is found that the activated carbon with used oil 1, used oil 2 and fresh oil provides continuous improvement of properties as per IEC (International Electrotechnical Commission) and ASTM (American Society for Testing and Materials) standards which will reduce the oil consumption and cost. From the analysis, it reveals that mineral oil with activated carbon has better properties and the use of activated carbon is the best practice of regeneration of oils.
- IEEE, Guide for Loading Mineral Oil Immersed Transformer (1995) Annexure I: Transformer Insulation Life, IEEE Standard C57.91.
- Rouse, T.O. (1998) “Mineral Oil in Transformers. IEEE Electrical Insulation Magazine, 14, 6-16. http://dx.doi.org/10.1109/57.675572
- Yuliastuti, E. (2010) Analysis of Dielectric Properties Comparison between Mineral Oil and Synthetic Ester Oil. Master of Science in Electrical Engineering Thesis, Delft University of Technology, Delft.
- Senthil Kumar, S., Willjuice Iruthayarajan, M. and Bakrutheen, M. (2014) Analysis of Vegetable Liquid Insulating Medium for Applications In High Voltage Transformers. IEEE International Conference on Science Engineering and Management Research, Chennai, 27-29 November 2014, 1-5.
- Ommen, T.V. (2003) Chemistry behind the Life of Transformer. Resonance, 8, 17-23.
- Hosier, L., Guushaa, A., Westenbrink, E.W., Rogers, C., Vaughan, A.S. and Swingler, S.G. (2011) Aging of Biodegradable Oils and Assessment of their Suitability for High Voltage Applications. IEEE Transactions on Dielectrics and Electrical Insulation, 18, 728-738. http://dx.doi.org/10.1109/TDEI.2011.5931059
- Young, W. (1998) Transformer Life Management—Condition Monitoring. Proceedings of the IEEE Colloquium Transformer Life Management, (Digest) IEEE Stevane, England, 1-4. http://dx.doi.org/10.1049/ic:19981006
- Okabe, S. and Kohtoh, M. (2010) Suppression of Increase in Electromagnetic Charging Tendency of Insulating Oil by Aging Used for Power Transformer Insulation. IEEE Transaction on Dielectrics and Electrical Insulation Magazine, 17, 473-480.
- Sierota, A. (1995) Electrical Insulating Oils Part I: Characterization and Pre-Treatment of New Transformer Oils. IEEE Transactions on Dielectrics and Electrical Insulation Magazine, 11, 8-20. http://dx.doi.org/10.1109/57.342040
- Schaut, A., Autru, S., De Rop, A. and Eeckhoudt, S. (2012) Effects of Irgament 30 as Additives in Transformer Oil. IEEE Transactions on Dielectrics and Electrical Insulation Magazine, 19, 175-180. http://dx.doi.org/10.1109/TDEI.2012.6148516
- AI-Zuhai, S. (2009) Using Activated Carbon from Waste Date-Pits as an Absorbent for Transformer Oil Regeneration. IEEE Transaction on Electrical Insulation Magazine, 25, 141-162.
- Lu Xl', (2010) The Study and Manufacture of the XD? Serials of Adsorbent and Its Efficiency of the Transformer Oil Treatment for a EHV Transformer. China International Conference on Electricity Distribution (CICED).