Assessment of Incineration Process Performance in a District Hospital Using Statistical Analysis
- 1 University of Dar es Salaam, Dar es Salaam, Tanzania
- 2 University of Dar es Salaam, Dar es Salaam, Tanzania
Abstract
The objective of this study was to assess the performance of an old existing medical waste incinerator in a district (Temeke) hospital. The medical waste incinerated was grouped into two categories: sharps waste and other waste. The parameters assessed included amounts of sharps and other waste incinerated, amount of fuel used and the incineration cycle time. One incineration cycle was conducted per day and data was collected for 22 months (N = 653). It was established that the total waste incinerated per day ranged from 70 to 120 kg, completing the process between 2 and 4 hrs and consuming 20 to 40 L of fuel per day. The analysis showed further that sharps waste incinerated were 25% of the total waste while other waste incinerated were about 75% on average. The average diesel oil used was 30 L/day and average cycle time was observed to be 3 hrs, both being excessively high indicating that the performance of the incin-erator was poor. The statistical analysis was used to reveal stronger variations in other waste than sharps waste. The PDF plots, skewness and kurtosis values indicated that there were weak variations in the daily diesel oil consumed and incineration cycle time while stronger variations were observed in the other waste compared to sharps waste data. Normalization of the incinerator performance data allowed comparison between different data types also indicating poor performance of the incinerator. Proper segregation at point of generation and proper storage of medical waste was recommended. It was further recommended for the hospital to install a new and efficient incinerator with short incineration cycle time and less fuel consumption.
- S. V. Manyele and C. M. Mujuni, “Current Status of Sharps Waste Management in Lower Level Health Facilities in Tanzania,” Tanzania Health Research Journal, Vol. 12, No. 4, 2010, pp. 257-264.
- Environmental Protection Agency (EPA), “Guide for Infectious Waste Management,” Office of Solid Waste and Emergency Response, Washington DC, 1997.
- S. V. Manyele and T. J. Lyasenga, “Factors Affecting Medical Waste Management in the Lower-Level Health Facilities,” African Journal of Environmental Science and Technology, Vol. 4, No. 5, 2008, pp. 304-318.
- F. Powell, “Air Pollutant Emissions from the Incineration of Hospital Wastes: The Alberta Experience,” Journal of the Air Pollution Control Association, Vol. 37, No. 7, 1987, pp. 836-839.
- L. Brna and J. Kilgroe, “Hospital Incinerator Emissions, Risks and Permitting: A Case Study,” The 80th Annual Meeting of Air Pollution Control Association, New York, 21-26 June 1989.
- S. V. Manyele, “Toxic Acid Gas Absorber Design Considerations for Air Pollution Control in Process Industries,” Educational Research and Reviews, Vol. 3, No. 4, 2008, pp. 137-147.
- S. V. Manyele, H. Anicetus and M. H. Bilia, “Globalization and Its Effects on Medical Waste Management in Tanzania,” Proceedings of IET Annual Conference and General Meeting, Arusha, 4-5 December 2003, pp. 76-92.
- S. V. Manyele, “Medical Waste Management in Tanzania: Current Situation and the Way Forward,” African Journal of Environmental Assessment and Management, Vol. 8, No. 1, 2004, pp. 74-99.
- S. V. Manyele and H. Anicetus, “Management of Medical Waste in Tanzanian Hospitals,” Tanzania Health Research Bulletin, Vol. 8, No. 3, 2006, pp. 177-182.
- W. A. Rutala, M. M. Stiegel and F. A. Sarubbi Jr., “Decontamination of Laboratory Microbiological Waste by Steam Sterilization,” Applied and Environmental Microbiology, Vol. 43, No. 3, 1992, pp. 1311-1316.
- J. Yaukey, “Incinerator Critic Blasts Cornell Plan,” Ithaca Journal, 18 September 1996.
- W. C. Blackman Jr., “Basic Hazardous Waste Management,” 2nd Edition, Lewis Publishers, Boca Raton, 1996.
- L. Llyod, “Working Paper on Small-Scale Incineration,” The East & Southern Africa Healthcare Waste Management Meeting, Dar es Salaam, 9-11 June 2003.
- E. T. Oppelt “Incineration of Hazardous Waste—A Critical Review,” Journal of the Air Pollution Control Association, Vol. 37, No. 5, 2007, pp. 558-586.