Analysis for Effects of Temperature Rise of PV Modules upon Driving Distance of Vehicle Integrated Photovoltaic Electric Vehicles — Oak Academic Publishing
Research ArticleOpen AccessGoogle Scholar indexed
Analysis for Effects of Temperature Rise of PV Modules upon Driving Distance of Vehicle Integrated Photovoltaic Electric Vehicles
Toyota Technological Institute, Nagoya, Japan
,
Faculty of Engineering, Miyazaki University, Miyazaki, Japan
,
Toyota Motor Corporation, Susono, Japan
,
European Commission—Joint Research Centre, Ispra, Italy
,
European Commission—Joint Research Centre, Ispra, Italy
,
European Commission—Joint Research Centre, Ispra, Italy
,
Faculty of Engineering, Miyazaki University, Miyazaki, Japan
,
Faculty of Engineering, Miyazaki University, Miyazaki, Japan
,
Sharp Corporation, Nara, Japan
,
Toyota Motor Corporation, Toyota, Japan
,
Toyota Motor Corporation, Toyota, Japan
,
Nissan Motor Corporation, Yokosuka, Japan
,
Nissan Motor Corporation, Yokosuka, Japan
,
Nissan Motor Corporation, Yokosuka, Japan
,
Toyota Motor Corporation, Susono, Japan
,
Toyota Motor Corporation, Susono, Japan
,
Toyota Motor Corporation, Susono, Japan
,
Toyota Technological Institute, Nagoya, Japan
,
Toyota Technological Institute, Nagoya, Japan
,
Toyota Technological Institute, Nagoya, Japan
,
Toyota Technological Institute, Nagoya, Japan
1 Toyota Technological Institute, Nagoya, Japan
2 Faculty of Engineering, Miyazaki University, Miyazaki, Japan
3 Toyota Motor Corporation, Susono, Japan
4 European Commission—Joint Research Centre, Ispra, Italy
5 European Commission—Joint Research Centre, Ispra, Italy
6 European Commission—Joint Research Centre, Ispra, Italy
7 Faculty of Engineering, Miyazaki University, Miyazaki, Japan
8 Faculty of Engineering, Miyazaki University, Miyazaki, Japan
The development of vehicle integrated photovoltaics-powered electric vehicles (VIPV-EV) significantly reduces CO 2 emissions from the transport sector to realize a decarbonized society. Although long-distance driving of VIPV-EV without electricity charging is expected in sunny regions, driving distance of VIPV-EV is affected by climate conditions such as solar irradiation and temperature rise of PV modules. In this paper, detailed analytical results for effects of climate conditions such as solar irradiation and temperature rise of PV modules upon driving distance of the VIPV-EV were presented by using test data for Toyota Prius and Nissan Van demonstration cars installed with high-efficiency InGaP/GaAs/InGaAs 3-junction solar cell modules with a module efficiency of more than 30%. The temperature rise of some PV modules studied in this study was shown to be expressed by some coefficients related to solar irradiation, wind speed and radiative cooling. The potential of VIPV-EV to be deployed in 10 major cities was also analyzed. Although sunshine cities such as Phoenix show the high reduction ratio of driving range with 17% due to temperature rise of VIPV modules, populous cities such as Tokyo show low reduction ratio of 9%. It was also shown in this paper that the difference between the driving distance of VIPV-EV driving in the morning and the afternoon is due to PV modules’ radiative cooling. In addition, the importance of heat dissipation of PV modules and the development of high-efficiency PV modules with better temperature coefficients was suggested in order to expand driving range of VIPV-EV. The effects of air-conditioner usage and partial shading in addition to the effects of temperature rise of VIPV modules were suggested as the other power losses of VIPV-EV.
Rodriguez, A.S., De Santana, T., MacGill, I., Ekins-Daukes, N.J. and Reinders, A. (2019) A Feasibility Study of Solar PV-Powered Electric Cars Using an Interdisciplinary Modeling Approach for the Electricity Balance, CO 2 Emissions, and Economic Aspects: The Cases of the Netherlands, Norway, Brazil, and Australia. Progress in Photovoltaics : Research and Applications , 28, 517-532. https://doi.org/10.1002/pip.3202
Yamaguchi, M., Masuda, T., Araki, K., Sato, D., Lee, K-H., Kojima, N., Takamoto, T., et al . (2020) Role of PV-Powered Vehicles in Low-Carbon Society and Some Approaches of High-Efficiency Solar Cell Modules for Cars. Energy and Power E n gineering , 12, 375-395. https://doi.org/10.4236/epe.2020.126023
Yamaguchi, M., Masuda, T., Nakado, T., Yamada, K., Okumura, K., Satou, A., et al . (2023) Analysis for Expansion of Driving Distance and CO 2 Emission Reduction of Photovoltaic-Powered Vehicles. IEEE Journal of Photovoltaics , 13, 343-348. https://doi.org/10.1109/JPHOTOV.2023.3242125
Yamaguchi, M., Masuda, T., Araki, K., Sato, D., Lee, K-H., Kojima, N., et al . (2021) Development of High-Efficiency and Low-Cost Solar Cells for PV-Powered Vehicles Application. Progress in Photovoltaics : Research and Applications , 29, 684-693. https://doi.org/10.1002/pip.3343
Masuda, T., Nakado, T., Yamaguchi, M., Takamoto, T., Nishioka, K. and Yamada, K. (2022) Public Road Tests of Toyota Prius Equipped with High Efficiency PV Modules with Output Power of 860 W. Proceedings of the 49 th IEEE Photovoltaic Specialists Conference , Philadelphia, 5-10 June 2022, 263. https://doi.org/10.1109/PVSC48317.2022.9938532
Yamaguchi, M., Masuda, T., Tanimoto, T., Tomita, Y., Ota, Y., Thiel, C., et al . (2023) Analysis for Effects of Temperature Rise of Solar Cell Modules upon Driving Distance of Photovoltaics-Powered Vehicles. Proceedings of the 50 th IEEE Phot o voltaic Specialists Conference , San Juan, 11-16 June 2023, 1. https://doi.org/10.1109/PVSC48320.2023.10359881
Yamaguchi, M., Masuda, T., Araki, K., Ota, Y., Nishioka, K., Takamoto, T., et al . (2021) Analysis for Temperature Coefficient and Their Effect on Efficiency of Solar Cell Modules for Photovoltaics-Powered Vehicles. Journal of Physics D : Applied Physics , 54, Article ID: 504002. https://doi.org/10.1088/1361-6463/ac1ef8
Wheeler, A., Leveille, M., Anton, I., Leilaeioun, A. and Kurtz, S. (2019) Determining the Operating Temperature of Solar Panel on Vehicles. Proceedings of the 47 th IEEE Photovoltaic Specialists Conference , Calgary, 15-21 June 2020, 894. https://doi.org/10.1109/PVSC40753.2019.9311292
Yukawa, M., Asaoka, M., Takahara, K., Ohshiro, T. and Kurokawa, K. (1996) Estimation of Photovoltaic Module Temperature Rise. Trans. IEEJ Journal of Industry Applications , 116-B, 1101-1110. (In Japanese) https://doi.org/10.1541/ieejpes1990.116.9_1101
Wheeler, A., Leveille, M., Anton, I., Limpinsel, M. and Kurtz, S. (2019) Outdoor Performance of PV Technologies in Simulated Automotive Environments. Pr o ceedings of the 47 th IEEE Photovoltaic Specialists Conference , Calgary, 15 June-21 August 2020, 898. https://doi.org/10.1109/PVSC40753.2019.8981352
King, D.L., Boyson, W.E. and Kratochvill, J.A. (2004) Photovoltaic Array Performance Model, Sandia Report: SAND2004-3535. Sandia National Laboratories, Albuquerque. https://www.semanticscholar.org/paper/sandia
Muller, M., Marion, B. and Rodriguez, J. (2012) Evaluating the IEC 61215 Ed.3 NMOT Procedure against the Existing NOCT Procedure with PV Modules in a Side-by-Side Configuration. Proceedings of the 38 th IEEE Photovoltaic Specialists Conference , Austin, 3-8 June 2012, 697. https://doi.org/10.1109/PVSC.2012.6317705
Ota, Y., Araki, K., Nagaoka, A. and Nishioka, K. (2021) Evaluating the Output of a Car-Mounted Photovoltaic Module under Driving Conditions. IEEE Journal of Photovoltaics , 11, 1299-1304. https://doi.org/10.1109/JPHOTOV.2021.3087748
Nishikawa, S. (1997) Characteristics of PV Cell Temperature and Cooling Effects on a Stand-Off Type PV Array. Journal of Japan Solar Energy Society , 23, 52. (In Japanese)
Zhu, I., Raman, A., Wang, K.X., Anoma, M.A. and Fang, S. (2014) Radiative Cooling of Solar Cells. Optica , 1, 32-38. https://doi.org/10.1364/OPTICA.1.000032
Sato, D. and Yamada, N. (2019) Review of Photovoltaic Module Cooling Methods and Performance Evaluation of the Radiative Cooling Method. Renewable and Su s tainable Energy Review , 104, 151-166. https://doi.org/10.1016/j.rser.2018.12.051
Li, Z., Ahmed, S. and Ma, T. (2021) Investigating the Effect of Radiative Cooling on the Operating Temperature of Photovoltaic Modules. Solar RRL , 5, Article ID: 2000735. https://doi.org/10.1002/solr.202000735
Fan, J.C.C. (1986) Theoretical Temperature Dependence of Solar Cell Parameters. Solar Cells , 17, 309-315. https://doi.org/10.1016/0379-6787(86)90020-7
Abderrezek, M., Fathi, M., Mekhilef, S. and Djahli, F. (2015) Effects of Temperature on the GaInP/GaAs Tandem Solar Cell Performances. International Journal of R e newable Energy Research , 5, 629-634. https://www.researchgate.net/publication/279915931
Dupre, O., Vaillon, R. and Green, M.A. (2015) Physics of the Temperature Coefficients of Solar Cells. Solar Energy Materials and Solar Cells , 140, 92-100. https://doi.org/10.1016/j.solmat.2015.03.025
Yoshida, S. (1983) Study on Development of High Performance and Highly Reliable (AlGa)As/GaAs Solar Cells. PhD Thesis, Tokyo Inst. Tech., Tokyo. (In Japanese) https://topics.libra.titech.ac.jp/recordid/catalog.bib/1000262268
Siefer, G. and Bett, A.W. (2014) Analysis of Temperature Coefficients for III-V Multi-Junction Concentrator Cells. Progress in Photovoltaics : Research and Appl i cations , 22, 515-524. https://doi.org/10.1002/pip.2285
Hishikawa, Y., Doi, T., Yamagoe, K., Ohshima, H., Takenouchi, T. and Yoshita, M. (2018) Voltage-Dependent Temperature Coefficient of the I-V Curves of Crystalline Silicon Photovoltaic Modules. IEEE Journal of Photovoltaics , 8, 48-53. https://doi.org/10.1109/JPHOTOV.2017.2766529
Masuda, T., Araki, K., Okumura, K., Urabe, S., Kudo, Y., Kimura, K., Nakado, T., Sato, A. and Yamaguchi, M. (2017) Static Concentrator Photovoltaics for Automotive Applications. Solar Energy , 46, 523-531. https://doi.org/10.1016/j.solener.2017.03.028
Thiel, C., Amillo, A.G., Tansini, A., Tsakalidis, A., Fontaras, G., Dunlop, E., et al . (2022) Impact of Climatic Conditions on Prospects for Integrated Photovoltaics in Electric Vehicles. Renewable and Sustainable Energy Review , 158, Article ID: 112109. https://doi.org/10.1016/j.rser.2022.112109
Weatherspark. https://ja.weatherspark.com/
Yamaguchi, M., Nakamura, K., Ozaki, R., Kojima, N., Ohshita, Y., Masuda, T., et al . (2023) Analysis of Climate Conditions upon Driving Distance of Vehicle Integrated Photovoltaics-Powered Vehicles. Energy Technology , 12, Article ID: 2300692. https://doi.org/10.1002/ente.202300692
Tanimoto, T. (2022) Demonstration Test of EV Equipped with a Solar Power Generation System That Utilizes Solar Energy for Driving. The 33 rd International Ph o tovoltaic Science and Engineering Conference ( PVSEC -33), Nagoya, 14-17 2022 November, ThO-22c-01.
Tomita, Y., Saito, M., Nagai, Y., Zushi, Y., Tanimoto, T. and Nishijima, K. (2021) Development of Electric Vehicle with a High Power Photovoltaic System. 5 th I n ternational Electric Vehicle Technology Conference ( EVTech ), No. 20214307.
Hirota, T., Kim, Y., Kobayashi, K., Kamiya, Y., Maeshima, S. and Komoto, K. (2022) Feasibility Study of Onboard PV for Passenger Vehicle Application (Second Report)—Influence of Vehicle Irradiation on Energy Balance of PV Generation and EV Energy Consumption. Transactions of Society of Automotive Engineers of J a pan , 53, 784-789. (In Japanese)