Metallic pipeline corrosion poses a significant challenge in the petrochemical industry. In this study, the design and control of a stand-alone photovoltaic (PV)-powered cathodic protection (CP) system based on the impressed current method were investigated. The proposed CP system was applied to a 250 km long steel-buried pipeline in the Sharm El-Sheikh region of Egypt. The system design involved the numerical modeling of the anode bed for the impressed current CP (ICCP) system and the sizing of the DC power source, including the PV array and battery bank. The system was designed and controlled to deliver a constant and continuous anode current to protect the underground pipeline from corrosion during daylight and nighttime. A maximum power point tracking (MPPT) algorithm based on the fractional open-circuit voltage (FOCV) technique was implemented to maximize power extraction from the PV array. Additionally, a proportional-integral (PI) controller was optimized and employed to achieve MPPT, while another PI controller managed the anode current of the CP system. Safe charging and discharging of the system’s battery are ensured via an ON-OFF controller. The parameters of the PI controllers were optimized using the particle swarm optimization (PSO) technique. Simulation results demonstrated that the proposed CP system achieved the required protection objectives successfully.
Al-Moubaraki, A.H. and Obot, I.B. (2021) Corrosion Challenges in Petroleum Refinery Operations: Sources, Mechanisms, Mitigation, and Future Outlook. Journal of Saudi Chemical Society , 25, Article ID: 101370. https://doi.org/10.1016/j.jscs.2021.101370
Maka, A.O.M., Chaudhary, T.N., Alaswad, G. and Elsayah, O. (2024) Applications of Solar Photovoltaics in Powering Cathodic Protection Systems: A Review. Clean Technologies and Environmental Policy , 26, 2755-2776. https://doi.org/10.1007/s10098-024-02750-0
Alamri, A.H. (2020) Localized Corrosion and Mitigation Approach of Steel Materials Used in Oil and Gas Pipelines—An Overview. Engineering Failure Analysis , 116, Article ID: 104735. https://doi.org/10.1016/j.engfailanal.2020.104735
Carmona, J., Garcés, P. and Climent, M.A. (2015) Efficiency of a Conductive Cement-Based Anodic System for the Application of Cathodic Protection, Cathodic Prevention and Electrochemical Chloride Extraction to Control Corrosion in Reinforced Concrete Structures. Corrosion Science , 96, 102-111. https://doi.org/10.1016/j.corsci.2015.04.012
Ashworth, V. (2010) Principles of Cathodic Protection. In: Richardson, T.J.A., Ed., Shreir ’ s Corrosion , Elsevier, 2747-2762. https://doi.org/10.1016/b978-044452787-5.00152-9
Ameh, E.S. and Ikpeseni, S.C. (2018) Pipelines Cathodic Protection Design Methodologies for Impressed Current and Sacrificial Anode Systems. Nigerian Journal of Technology , 36, 1072-1077. https://doi.org/10.4314/njt.v36i4.12
Abdulamer, D. and Abdulamer, D.N. (2013) Effect of Soil Resistivities for Different Geometrical Anodes on Design Photovoltaic for Cathodic Protection System. Global Research Analysis , 2, 36-40. https://www.researchgate.net/publication/348550363
Abdulamer, D.N. (2013) Effect of Soil Resistivity on the Design of Sacrificial Anode Cathodic Protection System. Journal of Petroleum Research and Studies , 4, 142-158. https://doi.org/10.52716/jprs.v4i3.121
Al-Refai, M.A. (2019) Optimal Design and Simulation of Solar Photovoltaic Powered Cathodic Protection for Underground Pipelines in Libya. J ournal of Electrical Engineering , 7, 61-74. https://doi.org/10.17265/2328-2223/2019.02.004
Mohammed, S.A.H. and Abdulbaqi, I.M. (2018) Numerical Study and Design of an Impressed Current Cathodic Protection System for Buried Metallic Pipes. 2018 Third Scientific Conference of Electrical Engineering ( SCEE ), Baghdad, 19-20 December 2018, 95-100. https://doi.org/10.1109/scee.2018.8684076
Mohammed, S.A.D.H. and Abdulbaqi, I.M. (2020) Design and Implementation of an Impressed Current Cathodic Protection System for Buried Metallic Pipes (Part II) (Considering Al-Quds Gas Station in Baghdad). International Journal of Power Electronics and Drive Systems ( IJPEDS ), 11, 275-293. https://doi.org/10.11591/ijpeds.v11.i1.pp275-283
Khudoyorov, K.D. (2022) Automatic Control of Photovoltaic Cathodic Protection System Used for Various Metals. Applied Solar Energy , 58, 244-249. https://doi.org/10.3103/s0003701x22020098
Javidan, J. (2016) Energy Management Strategy of Stand-Alone Photovoltaic System in Cathodic Protection Pipeline. Journal of Operation and Automation in Power Engineering , 4, 143-152. http://joape.uma.ac.ir
Javadi, M., Javidan, J. and Salimi, M. (2014) Design an Intelligent Solar Photovoltaic Power for Cathodic Protection System to Protect Under Ground Gas Pipeline. International Journal on Technical and Physical Problems of Engineering , 18, 27-33. http://www.iotpe.com
Haddadi, M., Ali, M. and Krishan, M. (2009) Optimized Design of a Photovoltaic Cathodic Protection. The Arabian Journal for Science and Engineering , 34, 477-489. https://www.researchgate.net/publication/228675646
Laoun, B., Niboucha, K. and Serir, L. (2023) Cathodic Protection of a Buried Pipeline by Solar Energy. Journal of Renewable Energies , 12, 99-104. https://doi.org/10.54966/jreen.v12i1.123
Samir Adly, G., Anis, W.R. and Hafez, I.M. (2017) Design of Photovoltaic Powered Cathodic Protection System. International Journal of Scientific & Technology Research , 6, 246-253. https://www.ijstr.org
Sada, B., Ali, R. and Ali, K. (2016) Identification and Control of Impressed Current Cathodic Protection System. Iraqi Journal for Electrical and Electronic Engineering , 12, 214-220. https://doi.org/10.37917/ijeee.12.2.12
Javadi, M., Javidan, J. and Salimi, M. (2014) Cathodic Protection of an Underground Pipeline by Photovoltaic Power System Using Intelligent Method. International Journal of Renewable Energy Research , 4, 267-274.
Akcayol, M.A. (2006) Application of Fuzzy Logic Controlled Cathodic Protection on Iraq-Turkey Crude Oil Pipeline. Applied Intelligence , 24, 43-50. https://doi.org/10.1007/s10489-006-6928-x
Samoudi, A.J.K. (2015) Design and Simulation of Solar Photovoltaic Powered Cathodic Protection Systems. Master Thesis, An-Najah National University.
Nafeh, A.E.A. (2009) Design and Economic Analysis of a Stand-Alone PV System to Electrify a Remote Area Household in Egypt. The Open Renewable Energy Journal , 2, 33-37. https://doi.org/10.2174/1876387100902010033
Zahedi, A. and Kalam, A. (2000) Balancing Cost and Performance in a PV/Wind/Battery Hybrid Power System. 2020 Australasian Universities Power Engineering Conference ( AUPEC 2020), 29 November-3 December 2020, Hobart, 1-5.
Mosalam Shaltout, M.A. (1998) Egyptian Solar Radiation Atlas. New and Renewable Energy Authority, Ministry of Electrical and Energy, Egypt.
Hassan, A.A., Fahmy, F.H., Nafeh, A.E.S.A. and Youssef, H.K.M. (2022) Control of Three-Phase Inverters for Smart Grid Integration of Photovoltaic Systems. Journal of Electrical Systems , 18, 109-131.
Frezzetti, A., Manfredi, S. and Suardi, A. (2014) Adaptive Focv-Based Control Scheme to Improve the MPP Tracking Performance: An Experimental Validation. IFAC Pro ceedings Volumes , 47, 4967-4971. https://doi.org/10.3182/20140824-6-za-1003.02464
Eberhart, R. and Kennedy, J. (1995) A New Optimizer Using Particle Swarm Theory. MHS ’95. Proceedings of the Sixth International Symposium on Micro Machine and Human Science , Nagoya, 4-6 October 1995, 39-43. https://doi.org/10.1109/mhs.1995.494215
Gad, A.G. (2022) Particle Swarm Optimization Algorithm and Its Applications: A Systematic Review. Archives of Computational Methods in Engineering , 29, 2531-2561. https://doi.org/10.1007/s11831-021-09694-4