Numerical Study of Methane Dry Reforming Reaction in a Disk Reactor with Focused Solar Simulator
- 1 School of Intelligent Systems Engineering, Sun Yat-sen University, Guangzhou, China
- 2 School of Materials and Engineering, Sun Yat-sen University, Guangzhou, China
- 3 School of Materials and Engineering, Sun Yat-sen University, Guangzhou, China
Abstract
Heat transfer and thermochem i cal energy storage process of methane dry reforming in a disk reactor with focused solar simulator was modeled and analyzed. The results showed that thermochemical energy storage efficiency of disk reactor can reach 28.4%, and that is higher than that of tubular reactor. The maximum reaction rate occurs at catalyst bed corner near the baffle, because the corner has high temperature and high reactant molar fraction. As reactant flow increases, methane conversion and thermochemical energy storage efficiency decrease as catalyst bed temperature and heat loss decrease. The thermochemical energy storage efficiency increased first and then decreased with methane molar ratio increasing, while methane conversion and the thermochemical energy storage efficiency increased with reactant temperature increasing. As catalyst bed porosity rises, methane conversion and thermochemical energy storage efficiency increased first and then decreased, and optimum porosity is 0.31.
- Dai, L., Long, X.F., Lou, B., Zhou, S.Q. and Xu, Y. (2018) Progress in Thermochemical Energy Storage for Concentrated Solar Power: A Review. International Journal of Energy Research, 42, 4546-4561. https://doi.org/10.1002/er.4183
- Wang, X.H., Du, X.C. and Wei, J.J. (2017) Research Progress of Different Solar Thermochemical Energy Storage Systems. Chinese Science Bulletin, 62, 3631-3642. https://doi.org/10.1360/N972017-00398
- Spiewak, I., Tyner, C.E. and Langnickel, U. (1993) Applications of Solar Reforming Technology. https://doi.org/10.2172/10131314
- Manfred, B., Ulrich, L. and Manuel, S. (1991) Solar Steam Reforming of Methane. Solar Energy Materials, 43, 441-448. https://doi.org/10.1016/0165-1633(91)90081-U
- Bohmer, M., Langnickel, U. and Sanchez, M. (1991) Solar Steam Reforming of Methane. Solar Energy Materials, 24, 441-448. https://doi.org/10.1016/0165-1633(91)90081-U
- Buck, R., Muir, J.F. and Hogan, R.E. (1991) Carbon Dioxide Reforming of Methane in a Solar Volumetric Receiver/Reactor: The CAESAR Project. Solar Energy Materials, 24, 449-463. https://doi.org/10.1016/0165-1633(91)90082-V
- Muir, J.F., Hogan Jr., R.E., Skocypec, R.D. and Buck, R. (1991) Solar Reforming of Methane in a Direct Absorption Catalytic Reactor on a Parabolic Dish: I—Test and Analysis. Solar Energy, 52, 467-477. https://doi.org/10.1016/0038-092X(94)90654-8
- Spiewak, I., Epstein, M. and Segal, A. (1991) The Weizmann Institute of Science 480-kW Reformer System. IEA SSPS Task V. Proceedings of the Workshop on Methane Reforming, Koeln, 11-13 June 1991, 129-137.
- Jin, J., Wei, X., Liu, M.K., Yu, Y.H., Li, W.J., Kong, H. and Hao, Y. (2018) A Solar Methane Reforming Reactor Design with Enhanced Efficiency. Applied Energy, 226, 797-807. https://doi.org/10.1016/j.apenergy.2018.04.098
- Rubin, R., Karni, J. and Yeheskel, J. (2004) Chemical Kinetics Simulation of High Temperature Hydrocarbons Reforming in a Solar Reactor. Journal of Solar Energy Engineering, 126, 858-866. https://doi.org/10.1115/1.1691439
- Akpan, E., Sun, Y., Kumar, P., et al. (2007) Kinetics, Experimental and Reactor Modeling Studies of the Carbon Dioxide Reforming of Methane (CDRM) over a New Ni/CeO2-ZrO2 Catalyst in a Packed Bed Tubular Reactor. Chemical Engineering Science, 62, 4012-4024. https://doi.org/10.1016/j.ces.2007.04.044
- Akbari, M.H., Ardakani, A.H. and Tadbir, M.A. (2011) A Microreactor Modeling, Analysis and Optimization for Methane Autothermal Reforming in Fuel Cell Applications. Chemical Engineering Journal, 166, 1116-1125. https://doi.org/10.1016/j.cej.2010.12.044