Carbon monoxide (CO) emissions from corn silage were observed using Fourier Transform Infrared (FTIR) spectroscopy and laser spectroscopy. In the first experiment, corn silage was produced using laboratory bucket silos. Air samples were collected from the bucket silos during the first week of ensiling and analyzed using a low-resolution Bruker FTIR spectrometer coupled with a long optical path length White Cell. The CO concentration in the bucket silo gas, derived from the FTIR spectra using the LINEFIT program, was as high as 48.0 ppm. In the second experiment, air samples were collected through a flux chamber from an Ag-Bag silage pile on a commercial dairy that was opened several months after ensiling. The Ag-Bag air samples were analyzed using a high-resolution Bruker FTIR spectrometer, and CO concentrations were retrieved to be 6.83 ppm, corresponding to an area emission rate of 33.7 mg/(hour ·m 2 ). An LGR N 2 O/CO gas analyzer based on infrared laser spectroscopy was also used to measure the CO concentrations from the same flux chamber. Elevated CO concentrations were observed from these silage sources. The present study revealed that CO was emitted by corn silage during different phases of ensiling. Annual CO emissions from the corn silage were estimated to be much lower than those from the well-known emission categories in San Joaquin Valley (SJV) and California, but comparable to those from food and agricultural sources in the SJV. It is also confirmed that FTIR spectroscopy is a viable method for measuring CO concentrations in complex gas mixtures, such as silage gas.
OSHA (U.S. Department of Labor, Occupational Safety and Health Administration) (2012) OSHA Fact Sheet: Carbon Monoxide Poisoning. Occupational Safety and Health Administration, Washington DC. https://www.osha.gov/OshDoc/data_General_Facts/carbonmonoxide-factsheet.pdf
Sillman, S. (1999) The Relation between Ozone, NOx and Hydrocarbons in Urban and Polluted Rural Environments. Atmospheric Environment, 33, 1821-1845. https://doi.org/10.1016/S1352-2310(98)00345-8
Finlayson-Pitts, B.J. and Pitts Jr., J.N. (1993) Atmospheric Chemistry of Tropospheric Ozone Formation: Scientific and Regulatory Implications. Air and Waste, 43, 1091-1100. https://doi.org/10.1080/1073161X.1993.10467187
Robbins, R.C., Borg, K.M. and Robinson, E. (1968) Carbon Monoxide in the Atmosphere. Journal of the Air Pollution Control Association, 18, 106-110. https://doi.org/10.1080/00022470.1968.10469094
Fazlzadeh, M., Rostami, R., Hazrat, S. and Rastgu, A. (2015) Concentrations of Carbon Monoxide in Indoor and Outdoor Air of Ghalyun Cafes. Atmospheric Pollution Research, 6, 550-555. https://doi.org/10.5094/APR.2015.061
EPA (U.S. Environmental Protection Agency) (2021) Criteria Air Pollutants. https://www.epa.gov/criteria-air-pollutants
Lowry, T. and Schuman, L.M. (1956) “Silo-Filler’s Disease”—A Syndrome Caused by Nitrogen Dioxide. Journal of the American Medical Association, 162, 153-160. https://doi.org/10.1001/jama.1956.02970200001001
Wang, L.C. and Burries, R.H. (1960) Mass Spectrometric Study of Nitrogenous Gases Produced by Silage. Journal of Agricultural and Food Chemistry, 8, 239-242. https://doi.org/10.1021/jf60109a023
Reid, W.S., Turnbull, J.E., Sabourin, H.M. and Ihnat, M. (1984) Silo Gas: Production and Detection. Canadian Agricultural Engineering, 25, 197-207.
Hafner, S.D., Howard, C., Muck, R.E., Franco, R.B., Montes, F., Green, P.G., Mitloehner, F., Trabue, S.L. and Rotz, C.A. (2013) Emission of Volatile Organic Compounds from Silage: Compounds, Sources, and Implications. Atmospheric Environment, 77, 827-839. https://doi.org/10.1016/j.atmosenv.2013.04.076
Hafner, S.D., Franco, R.B., Kung Jr., L., Rotz, C.A. and Mitloehner, F. (2014) Potassium Sorbate Reduces Production of Ethanol and 2 Esters in Corn Silage. J. Dairy Sci., 97, 7870-7878. https://doi.org/10.3168/jds.2014-8537
Zhao, Y., Wexler, A.S., Hase, F., Pan, Y. and Mitloehner, F.M. (2016) Detecting Nitrous Oxide in Complex Mixtures Using FTIR Spectroscopy: Silage Gas. Journal of Environmental Protection, 7, 1719-1729. https://doi.org/10.4236/jep.2016.712139
CDFA (California Department of Food and Agriculture) (2020) California Agricultural Statistics Review 2019-2020. California Department of Food and Agriculture, Sacramento. https://www.cdfa.ca.gov/Statistics/PDFs/2020_Ag_Stats_Review.pdf
Shahbandeh, M. (2021) Number of Milk Cows in the United States from 1999 to 2020. US Department of Agriculture, Washington DC. https://www.statista.com/statistics/194934/number-of-milk-cows-in-the-us-since-1999/
Shahbandeh, M. (2021) Production of Corn for Silage in the U.S. from 2000 to 2020. US Department of Agriculture, Washington DC. https://www.statista.com/statistics/190886/production-of-corn-for-silage-in-the-us-since-2000/
Shahbandeh, M. (2021) Top U States Based on Corn Production for Silage from 2014 to 2020. US Department of Agriculture, Washington DC. https://www.statista.com/statistics/191041/top-us-states-by-production-of-corn-for-silage/
Malkina, I.L., Kumar, A., Green, P.G. and Mitloehner, F.M. (2011) Identification and Quantitation of Volatile Organic Compounds Emitted from Dairy Silages and Other Feedstuffs. Journal of Environmental Quality, 40, 28-36. https://doi.org/10.2134/jeq2010.0302
Li, M., Shan, G., Zhou, H., Buescher, W., Maack, C., Jungbluth, K.H., Lipski, A., Grantz, D.A., Fan, Y., Ma, D., Wang, Z., Cheng, Q. and Sun, Y. (2017) CO2 Production, Dissolution and Pressure Dynamics during Silage Production: Multi-Sensor-Based Insight into Parameter Interactions. Scientific Reports, 7, Article No. 14721. https://doi.org/10.1038/s41598-017-14187-1
Zhao, Y., Strong, K., Kondo, Y., Koike, M., Matsumi, Y., Irie, H., Rinsland, C.P., Jones, N.B., Suzuki, K., Nakajima, H., Nakane, H. and Murata, I. (2002) Spectroscopic Measurements of Tropospheric CO, C2H6, C2H2, and HCN in Northern Japan. Journal of Geophysical Research: Atmospheres, 107, ACH 2-1-ACH 2-16. https://doi.org/10.1029/2001JD000748
Wunch, D., Taylor, J.R., Fu, D., Bernath, P., Drummond, J.R., Midwinter, C., Strong, K. and Walker, K.A. (2007) Simultaneous Ground-Based Observations of O3, HCl, N2O, and CH4 over Toronto, Canada by Three Fourier Transform Spectrometers with Different Resolutions. Atmospheric Chemistry and Physics, 7, 1275-1292. https://doi.org/10.5194/acp-7-1275-2007
Neal, W.M. and Becker, R.B. (1933) A Type of Laboratory Silo and Its Use with Crotalaria. Journal of Agricultural Research, 47, 617-625.
Johnson, H.E., Merry, R.J., Davies, D.R., Kell, D.B., Theodorou, M.K. and Griffith, G.W. (2005) Vacuum Packing: A Model System for Laboratory-Scale Silage Fermentations. Journal of Applied Microbiology, 98, 106-113. https://doi.org/10.1111/j.1365-2672.2004.02444.x
Eklund, B. (1992) Practical Guidance for Flux Chamber Measurements of Fugitive Volatile Organic Emission Rates. Journal of the Air & Waste Management Association, 42, 1583-1591. https://doi.org/10.1080/10473289.1992.10467102
Parker, D., Ham, J., Woodbury, B., Cai, L., Spiehs, M., Rhoades, M., Trabue, S., Casey, K., Todd, R. and Cole, A. (2013) Standardization of Flux Chamber and Wind Tunnel Flux Measurements for Quantifying Volatile Organic Compound and Ammonia Emissions from Area Sources at Animal Feeding Operations. Atmospheric Environment, 66, 72-83. https://doi.org/10.1016/j.atmosenv.2012.03.068
Hase, F., Blumenstock, T. and Paton-Walsh, C. (1999) Analysis of the Instrumental line Shape of High-Resolution Fourier Transform IR Spectrometers with Gas Cell Measurements and New Retrieval Software. Applied Optics, 38, 3417-3422. https://doi.org/10.1364/AO.38.003417
Hase, F. (2012) Improved Instrumental Line Shape Monitoring for the Ground-Based, High-Resolution FTIR Spectrometers of the Network for the Detection of Atmospheric Composition Change. Atmospheric Measurement Techniques, 5, 603-610. https://doi.org/10.5194/amt-5-603-2012
Hase, F., Drouin, B.J., Roehl, C.M., Toon, G.C., Wennberg, P.O., Wunch, D., Blumenstock, T., Desmet, F., Feist, D.G., Heikkinen, P., De Mazière, M., Rettinger, M., Robinson, J., Schneider, M., Sherlock, V., Sussmann, R., Té, Y., Warneke, T. and Weinzierl, C. (2013) Calibration of Sealed HCl Cells Used for TCCON Instrumental Line Shape Monitoring. Atmospheric Measurement Techniques, 6, 3527-3537. https://doi.org/10.5194/amt-6-3527-2013
Frey, M., Hase, F., Blumenstock, T., Groß, J., Kiel, M., Tsidu, G.M., Schäfer, K., Sha, M.K. and Orphal, J. (2015) Calibration and Instrumental Line Shape Characterization of a Set of Portable FTIR Spectrometers for Detecting Greenhouse Gas Emissions. Atmospheric Measurement Techniques, 8, 3047-3057. https://doi.org/10.5194/amt-8-3047-2015
USDA (United States Department of Agriculture) (2020) Milk Production. US Department of Agriculture, National Agricultural Statistics Service, Washington DC. https://www.nass.usda.gov/Publications/Todays_Reports/reports/mkpr0220.pdf
USDA (United States Department of Agriculture) (2020) California Corn County Estimates. US Department of Agriculture, National Agricultural Statistics Service, Washington DC. https://www.nass.usda.gov/Statistics_by_State/California/Publications/County_Estimates/2020/202002CORNCNTY.pdf
Amaral-Phillips, D.M. and McAllister, J. (2001) Planning the Yearly Forage and Commodity Needs for a Dairy Herd. University of Kentucky, Lexington. http://www2.ca.uky.edu/agcomm/pubs/asc/asc160/asc160.pdf
USDA (United States Department of Agriculture) (2020) California Cattle County Estimates. US Department of Agriculture, National Agricultural Statistics Service, Washington DC. https://www.nass.usda.gov/Statistics_by_State/California/Publications/County_Estimates/2020/CATCNTYE_1920.pdf
CARB (California Air Resources Board) (2018) CEPAM: 2016 SIP—Standard Emission Tool, Emission Projections by Summary Category Base Year: 2012. https://www.arb.ca.gov/app/emsinv/fcemssumcat/fcemssumcat2016.php