The potential of biodiesel fuels from various vegetable oil sources such as sunflower (SFME), safflower (SAFME), peanut (PME) and canola (CME) as well as from low-cost chicken fat (CFME) to supplement increasing biodiesel demands must be evaluated in terms of the corresponding engine performance and exhaust emissions. In this study, two diesel engines rated at 14.2 kW (small) and 60 kW (large) were operated by using the different biodiesel fuels and a reference diesel. Results showed that both the small and large engines delivered similar power when using biodiesel fuels in the expense of higher brake-specific fuel consumptions (BSFC). Higher exhaust concentrations of nitrogen oxides (NO x ) and carbon dioxide (CO 2 ) while lower carbon dioxide (CO) and negligible sulfur dioxide (SO 2 ) emissions were observed in both engines. Total hydrocarbon emissions (THC) were higher in both engines when using SME, SFME and CME but comparable when using CFME, SAFME and PME in the large engine. Thus, with the increasing demand for biodiesel, alternative feedstock sources such as those used in this study may be utilized to take advantage of their availability, renewability and environmental benefits.
Gumus, M., Sayin, C. and Canacki, M. (2010) Effect of Fuel Injection Timing on the Injection, Combustion, and Performance Characteristics of a Direct-Injection (DI) Diesel Engine Fueled with Canola Oil Methyl Ester-Diesel Fuel Blends. Energy Fuels, 24, 3199-3213. http://dx.doi.org/10.1021/ef9014247
McCarthy, P., Rasul, M.G. and Moazzem, S. (2011) Analysis and Comparison of Performance and Emissions of an Internal Combustion Engine Fuelled with Petroleum Diesel and Different Bio-Diesels. Fuel, 90, 2147-2157. http://dx.doi.org/10.1016/j.fuel.2011.02.010
Isigigur, A., Karaosmanoglu, F., Aksoy, H.A., Hamdullahpur, F. and Gulder, O.L. (1994) Performance and Emission Characteristics of a Diesel Engine Operating on Safflower Seed Oil Methyl Ester. Applied Biochemistry and Biotechnology, 45/46, 93-102. http://dx.doi.org/10.1007/BF02941790
Kocak, M.S., Ileri, E. and Utlu, Z. (2007) Experimental Study of Emission Parameters of Biodiesel Fuels Obtained from Canola, Hazelnut, and Waste Cooking Oils. Energy Fuels, 21, 3622-3626. http://dx.doi.org/10.1021/ef0600558
Demirbas, A. (2009) Progress and Recent Trends in Biodiesel Fuels. Energy Conversion and Management, 50, 14-34. http://dx.doi.org/10.1016/j.enconman.2008.09.001
Atabani, A.E., Silitonga, A.S., Badruddin, I.A., Mahalia, T.M.I., Masjuki, H.H. and Mekhilef, S. (2012) A Comprehensive Review on Biodiesel as an Alternative Energy Resource and Its Characteristics. Renewable & Sustainable Energy Reviews, 16, 2070-2093. http://dx.doi.org/10.1016/j.rser.2012.01.003
Canacki, M. and Van Gerpen, J. (2001) Biodiesel Production from Oils and Fats with High Free Fatty Acids. Transactions of the ASABE, 44, 1429-1436.
Alptekin, E. and Canacki, M. (2009) Characterization of the Key Fuel Properties of Methyl Ester-Diesel Fuel Blends. Fuel, 88, 75-80. http://dx.doi.org/10.1016/j.fuel.2008.05.023
Kinast, A.J. (2001) Production of Biodiesels from Multiple Feedstocks and Properties of Biodiesels and Biodiesel-Di-esel Blends. National Renewable Energy Laboratory, Golden. http://www.biofuels.coop/archive/biodiesel_report.pdf
National Bio-Diesel Board (2009) What Is Bio-Diesel? http://biodiesel.org/docs/ffs-basics/benefits-of-biodiesel.pdf?sfvrsn=4
Wyatt, V.T., Hess, M.A., Dunn, R.O., Foglia, T.A., Haas, M.J. and Marmer, W.N. (2005) Fuel Properties and Nitrogen Oxide Emission Levels of Biodiesel Produced from Animal Fats. Journal of the American Oil Chemists’ Society, 82, 585-591. http://dx.doi.org/10.1007/s11746-005-1113-2
Moser, B.R. (2009) Biodiesel Production, Properties, and Feedstocks. In Vitro Cellular & Developmental Biology— Plant, 45, 229-266. http://dx.doi.org/10.1007/s11627-009-9204-z
USDA (2013) US Bioenergy Statistics. http://www.ers.usda.gov/data-products/us-bioenergy-statistics.aspx
Hill, J., Nelson, E., Tilman, D., Polasky, S. and Tiffany, D. (2006) Environmental, Economic, and Energetic Costs and Benefits of Biodiesel and Ethanol Biofuels. Proceedings of the National Academy of Sciences of the United States of America, 103, 11206-11210. http://dx.doi.org/10.1073/pnas.0604600103
USDA (2013) US Crop Production Data. National Agricultural Statistics Service (NASS), Agricultural Statistics Board, United States Department of Agriculture (USDA).
Karmakar, A., Karmakar, S. and Mukherjee, S. (2010) Properties of Various Plants and Animals Feedstocks for Biodiesel Production. Bioresource Technology, 101, 7201-7210. http://dx.doi.org/10.1016/j.biortech.2010.04.079
O’Brien, R., Farr, W. and Wan, P. (2000) Introduction to Fats and Oils Technology. 2nd Edition, AOCS Press, Champaign.
Sabzalian, M.R., Saeidi, G. and Mirlohi, A. (2008) Oil Content and Fatty Acid Composition in Seeds of Three Safflower Species. Journal of the American Oil Chemists’ Society, 85, 717-721. http://dx.doi.org/10.1007/s11746-008-1254-6
Babcock, R.E., Clausen, E.C., Popp, M. and Schulte, W.B. (2008) Yield Characteristics of Biodiesel Produced from Chicken Fat-Tall Oil Blended Feedstocks. Completion Report, Project Number MBTC-2092 R. E. Department of Transportation Research and Special Programs Administration. http://www.researchgate.net/publication/253638502_Yield_Characteristics_of_ Biodiesel_Produced_from_Chicken_Fat-Tall_Oil_Blended_Feedstocks
Rashid, U., Anwar, F. and Arif, M. (2009) Optimization of Base Catalytic Methanolysis of Sunflower (Helianthus annuus) Seed Oil for Biodiesel Production by Using Response Surface Methodology. Industrial & Engineering Chemistry Research, 48, 1719-1726. http://dx.doi.org/10.1021/ie801136h
Taravus, S., Temur, H. and Yartasi, A. (2009) Alkali-Catalyzed Biodiesel Production from Mixtures of Sunflower and Beef Tallow. Energy Fuels, 23, 4112-4115. http://dx.doi.org/10.1021/ef900211n
Moser, B.R. (2008) Influence of Blending Canola, Palm, Soybean and Sunflower Oil Methyl Esters on Fuel Properties of Biodiesel. Energy Fuels, 22, 4301-4306. http://dx.doi.org/10.1021/ef800588x
Vicente, G., Coteron, A., Martinez, M. and Aracil, J. (1998) Application of the Factorial Design of Experiments and Response Surface Methodology to Optimize Biodiesel Production. Industrial Crops and Products, 8, 29-35. http://dx.doi.org/10.1016/S0926-6690(97)10003-6
Antolin, G., Tinaut, F.V., Briceno, Y., Castano, V., Perez, C. and Ramirez, A.I. (2002) Optimization of Biodiesel Production by Sunflower Oil Transesterification. Bioresource Technology, 83, 111-114. http://dx.doi.org/10.1016/S0960-8524(01)00200-0
Duz, M.Z., Saydut, A. and Ozturk, G. (2011) Alkali Catalyzed Transesterification of Safflower Seed Oil Assisted by Microwave Irradiation. Fuel Processing Technology, 92, 308-313. http://dx.doi.org/10.1016/j.fuproc.2010.09.020
Thomas, T.P., Birney, D.M. and Auld, D.L. (2013) Optimizing Esterification of Safflower, Cottonseed, Castor, and Used Cottonseed Oils. Industrial Crops and Products, 41, 102-106. http://dx.doi.org/10.1016/j.indcrop.2012.03.023
Rashid, U. and Anwar, F. (2008) Production of Biodiesel through Based-Catalyzed Transesterification of Safflower Oil Using an Optimized Protocol. Energy Fuels, 22, 1306-1312. http://dx.doi.org/10.1021/ef700548s
Kaya, C., Hamamci, C., Baysal, A., Akba, O., Erdogan, S. and Saydut, A. (2009) Methyl Ester of Peanut (Arachis hypogea L.) Seed Oil as a Potential Feedstock for Biodiesel Production. Renewable Energy, 34, 1257-1260. http://dx.doi.org/10.1016/j.renene.2008.10.002
Nguyen, T., Do, L. and Sabatini, D.A. (2010) Biodiesel Production via Peanut Oil Extraction Using Diesel-Based Reverse-Micellar Microemulsions. Fuel, 89, 2285-2291. http://dx.doi.org/10.1016/j.fuel.2010.03.021
Moser, B.R. (2012) Preparation of Fatty Acid Methyl Esters from Hazelnut, High-Oleic Peanut and Walnut Oils and Evaluation as Biodiesel. Fuel, 92, 231-238. http://dx.doi.org/10.1016/j.fuel.2011.08.005
Eskin, N.A.M. and McDonald, B.E. (1991) Canola Oil. BNF Nutrition Bulletin, 16, 138-146. http://dx.doi.org/10.1111/j.1467-3010.1991.tb01048.x
Jeong, G.T., Yang, H.S., Park, S.H. and Park, D.H. (2007) Optimization of Biodiesel Production from Rapeseed Oil Using Response Surface Methodology. Korean Journal of Biotechnology and Bioengineering, 22, 222-227.
Xie, W., Huang, X. and Li, H. (2007) Soybean Oil Methyl Esters Preparation Using NaX Zeolites Loaded with KOH as a Heterogeneous Catalyst. Bioresource Technology, 98, 936-939. http://dx.doi.org/10.1016/j.biortech.2006.04.003
Alptekin, E. and Canacki, M. (2010) Optimization of Pretreatment Reaction for Methyl Ester Production from Chicken Fat. Fuel, 89, 4035-4039. http://dx.doi.org/10.1016/j.fuel.2010.04.031
Alptekin, E. and Canacki, M. (2011) Optimization of Transesterification for Methyl Ester Production from Chicken Fat. Fuel, 90, 2630-2638. http://dx.doi.org/10.1016/j.fuel.2011.03.042
Kondamudi, N., Strull, J., Misra, M. and Mohapatra, S.K. (2009) A Green Process for Producing Biodiesel from Feather Meal. Journal of Agricultural and Food Chemistry, 57, 6163-6166. http://dx.doi.org/10.1021/jf900140e
Guru, M., Koca, A., Can, O., Clnar, C. and Sahin, F. (2010) Biodiesel Production from Waste Chicken Fat Based Sources and Evaluation with Mg Based Additive in a Diesel Engine. Renewable Energy, 35, 637-643. http://dx.doi.org/10.1016/j.renene.2009.08.011
Xue, J., Grift, T.E. and Hansen, A.C. (2011) Effect of Biodiesel on Engine Performances and Emissions. Renewable and Sustainable Energy Reviews, 15, 1098-1116. http://dx.doi.org/10.1016/j.rser.2010.11.016
Moreno, F., Muñoz, M. and Morea-Roy, J. (1999) Sunflower Methyl Ester as a Fuel for Automobile Diesel Engines. Transactions of the ASAE, 42, 1181-1185. http://dx.doi.org/10.13031/2013.13283
EPA (2004) Control of Emissions of Air Pollution from Nonroad Diesel Engines and Fuel; Final Rule. USEPA, Washington DC. http://www.regulations.gov/#!documentDetail;D=EPA-HQ-OAR-2003-0012-1104
Santos, B.S., Capareda, S.C. and Capunitan, J.A. (2013) Engine Performance and Exhaust Emissions of Peanut Oil Biodiesel. Journal of Sustainable Bioenergy Systems, 3, 272-286. http://dx.doi.org/10.4236/jsbs.2013.34037
SAE (2008) SAE J 1349: Engine Power Test Code—Spark Ignition and Compression Ignition—Net Power Rating. SAE, Troy, MI. http://standards.sae.org/j1349_200803/
Lin, B.F., Huang, J.H. and Huang, D.Y. (2009) Experimental Study of the Effects of Vegetable Oil Methyl Ester on DI Diesel Engine Performance Characteristics and Pollutant Emissions. Fuel, 88, 1779-1785. http://dx.doi.org/10.1016/j.fuel.2009.04.006
Qi, D.H., Geng, L.M., Chen, H., Bian, Y.Z.H., Liu, J. and Ren, X.C.H. (2009) Combustion and Performance Evaluation of a Diesel Engine Fueled with Biodiesel Produced from Soybean Crude Oil. Renewable Energy, 34, 2706-2713. http://dx.doi.org/10.1016/j.renene.2009.05.004
Ozsezen, A.N., Canakci, M., Turkcan, A. and Sayin, C. (2009) Performance and Combustion Characteristics of a DI Diesel Engine Fueled with Waste Palm Oil and Canola Oil Methyl Esters. Fuel, 88, 629-636. http://dx.doi.org/10.1016/j.fuel.2008.09.023
Oguz, H., Ögüt, H. and Eryilmaz, T. (2007) Investigation of Biodiesel Production, Quality and Performance in Turkey. Energy Sources, Part A: Recovery, Utilization, and Environmental Effects, 29, 1529-1535. http://dx.doi.org/10.1080/15567030600820567
Pulkrabek, W.W. (2004) Engineering Fundamentals of the Internal Combustion Engine. 2nd Edition, Pearson Prentice-Hall, Upper Saddle River.
Kaplan, C., Arslan, R. and Sürmen, A. (2006) Performance Characteristics of Sunflower Methyl Esters as Biodiesel. Energy Sources, Part A: Recovery, Utilization, and Environmental Effects, 28, 751-755. http://dx.doi.org/10.1080/15567030600820567
Kumar, N., Varun and Chauhan, S.R. (2013) Performance and Emission Characteristics of Biodiesel from Different Origins: A Review. Renewable and Sustainable Energy Reviews, 21, 633-658. http://dx.doi.org/10.1016/j.rser.2013.01.006
Muñoz, M., Moreno, F. and Morea, J. (2004) Emissions of an Automobile Diesel Engine Fueled with Sunflower Methyl Ester. Transactions of the ASAE, 47, 5-11. http://dx.doi.org/10.13031/2013.15859
Nabi, M.N., Hoque, S.M. and Akhter, M.S. (2009) Karanja (Pongamia pinnata) Biodiesel Production in Bangladesh, Characterization of Karanja Biodiesel and Its Effect on Diesel Emissions. Fuel Processing Technology, 90, 1080-1086. http://dx.doi.org/10.1016/j.fuproc.2009.04.014
Moser, F., Schlogl, H. and Wiesbauer, H. (1989) Behaviour of Rape Seed Oil Methyl Ester Fueled Tractor Engines and Field Experience. Proceedings of the CEC International Symposium on the Performance Evaluation of Automotive Fuels and Lubricants, CTCM/EFTC, Paris, May 1989.
Canacki, M. and Van Gerpen, J.H. (2003) Comparison of Engine Performance and Emissions for Petroleum Diesel Fuel, Yellow Grease Biodiesel, and Soybean Oil Biodiesel. Transactions of the ASAE, 46, 937-944.
Puhan, S., Vedaraman, N., Ram, B.V.B., Sankarnarayanan, G. and Jeychandran, K. (2005) Mahua Oil (Madhuca indica Seed Oil) Methyl Ester as Biodiesel-Preparation and Emission Characterstics. Biomass and Bioenergy, 28, 87-93. http://dx.doi.org/10.1016/j.biombioe.2004.06.002
Utlu, Z. and Kocak, M.S. (2008) The Effect of Biodiesel Fuel Obtained from Waste Frying Oil on Direct Injection Diesel Engine Performance and Exhaust Emissions. Renewable Energy, 33, 1936-1941. http://dx.doi.org/10.1016/j.renene.2007.10.006
Wu, F., Wang, J., Chen, W. and Shuai, S. (2009) A Study on Emission Performance of a Diesel Engine Fueled with Five Typical Methyl Ester Biodiesels. Atmospheric Environment, 43, 1481-1485. http://dx.doi.org/10.1016/j.atmosenv.2008.12.007
Puhan, S., Vedaraman, N., Sankaranarayanan, G. and Ram, B.V.B. (2005) Performance and Emission Study of Mahua Oil (Madhuca indica Oil) Ethyl Ester in a 4-Stroke Natural Aspirated Direct Injection Diesel Engine. Renewable Energy, 30, 1269-1278. http://dx.doi.org/10.1016/j.renene.2004.09.010
Aydin, H. and Bayindir, H. (2010) Performance and Emission Analysis of Cottonseed Oil Methyl Ester in a Diesel Engine. Renewable Energy, 35, 588-592. http://dx.doi.org/10.1016/j.renene.2009.08.009
Karabektas, M. (2009) The Effects of Turbocharger on the Performance and Exhaust Emissions of a Diesel Engine Fuelled with Biodiesel. Renewable Energy, 34, 989-993. http://dx.doi.org/10.1016/j.renene.2008.08.010
Buyukkaya, E. (2010) Effects of Biodiesel on a DI Diesel Engine Performance, Emission and Combustion Characteristics. Fuel, 89, 3099-3105. http://dx.doi.org/10.1016/j.fuel.2010.05.034
Ramadhas, A.S., Muraleedharan, C. and Jayaraj, S. (2005) Performance and Emission Evaluation of a Diesel Engine Fueled with Methyl Esters of Rubber Seed Oil. Renewable Energy, 30, 1789-1800. http://dx.doi.org/10.1016/j.renene.2005.01.009
Ulusoy, Y., Tekin, Y., Cetinkaya, M. and Karaosmanoglu, F. (2004) The Engine Tests of Biodiesel from Used Frying oil. Energy Sources, Part A: Recovery, Utilization, and Environmental Effects, 26, 927-932. http://dx.doi.org/10.1080/00908310490473219
Fontaras G., Karavalakis, G., Kousoulidou, M., Tzamkiozis, T., Ntziachristos, L., Bakeas, E., et al. (2009) Effects of Biodiesel on Passenger Car Fuel Consumption, Regulated and Non-Regulated Pollutant Emissions over Legislated and Real-World Driving Cycles. Fuel, 88, 1608-1617. http://dx.doi.org/10.1016/j.fuel.2009.02.011
Canacki, M. (2005) Performance and Emissions Characteristics of Biodiesel from Soybean Oil. Proceedings of the Institution of Mechanical Engineers, Part D: Journal of Automobile Engineering, 219, 915-922. http://dx.doi.org/10.1243/095440705X28736
Labeckas, G. and Slavinskas, S. (2006) The Effect of Rapeseed Oil Methyl Ester on Direct Injection Diesel Engine Performance and Exhaust Emissions. Energy Conversion and Management, 47, 1954-1967. http://dx.doi.org/10.1016/j.enconman.2005.09.003
Sahoo, P.K., Das, L.M., Babu, M.K.G. and Naik, S.N. (2007) Biodiesel Development from High Acid Value Polanga Seed Oil and Performance Evaluation in a CI Engine. Fuel, 86, 448-454. http://dx.doi.org/10.1016/j.fuel.2006.07.025
Carraretto, C., Macor, A., Mirandola, A., Stoppato, A. and Tonon, S. (2004) Biodiesel as Alternative Fuel: Experimental Analysis and Energetic Evaluations. Energy, 29, 2195-2211. http://dx.doi.org/10.1016/j.energy.2004.03.042