Blended Regenerative Anti-Lock Braking System and Electronic Wedge Brake Coordinate Control Ensuring Maximal Energy Recovery and Stability of All-Wheel-Motor-Drive Electric Vehicles — Oak Academic Publishing
Research ArticleOpen AccessGoogle Scholar indexed
Blended Regenerative Anti-Lock Braking System and Electronic Wedge Brake Coordinate Control Ensuring Maximal Energy Recovery and Stability of All-Wheel-Motor-Drive Electric Vehicles
Automotive Technologies, Budapest University of Technology and Economics, Budapest, Hungary
,
Automotive Technologies, Budapest University of Technology and Economics, Budapest, Hungary
1 Automotive Technologies, Budapest University of Technology and Economics, Budapest, Hungary
2 Automotive Technologies, Budapest University of Technology and Economics, Budapest, Hungary
ABS is an active safety system which showed a valuable contribution to vehicle safety and stability since it was first introduced. Recently, EVs with in-wheel- motors have drawn increasing attention owing to their greatest advantages. Wheels torques are precisely and swiftly controlled thanks to electric motors and their advanced driving techniques. In this paper, a regenerative-ABS control RABS is proposed for all-in-wheel-motors-drive EVs. The RABS is realized as a pure electronic braking system called brake-by-wire. A coordination strategy is suggested to control RABS compromising three layers. First, wheels slip control takes place, and braking torque is calculated in the higher layer. In the coordinate interlayer, torque is allocated between actuators ensuring maximal energy recovery and vehicle stability. While in the lower layer, actuator control is performed. The RABS effectiveness is validated on a 3-DOF EVSimulink model through two straight-line braking manoeuvres with low and high initial speeds of 50 km/h and 150 km/h, respectively. Both regular and emergency braking manoeuvres are considered with ABS enabled and disabled for comparison. Simulation results showed the high performance of the proposed RABS control in terms of vehicle stability, brake response, stopping distance, and battery re-charging.
Wang, F., Ye, P., Xu, X., Cai, Y., Ni, S. and Que, H. (2022) Novel Regenerative Braking Method for Transient Torsional Oscillation Suppression of Planetary-Gear Electrical Powertrain. Mechanical Systems and Signal Processing, 163, Article ID: 108187. https://doi.org/10.1016/j.ymssp.2021.108187
Gaurkar, P.V., Challa, A., Ramakrushnan, K., Subramanian, S.C., Vivekanandan, G. and Sivaram, S. (2021) Model Predictive Control of Wheel Slip towards Antilock Brake System Using Convex optimization. 2021 International Conference on COMmunication Systems and NETworkS, Bangalore, 5-9 January 2021, 644-649. https://doi.org/10.1109/COMSNETS51098.2021.9352848
Said Jneid, M. and Harth, P. (2003) Integrated Braking and Traction Torque Vectoring Control Based on Vehicle Yaw Rate for Stability Improvement of All-Wheel-Drive Electric Vehicles. 2023 IEEE International Conference on Electrical Systems for Aircraft, Railway, Ship Propulsion and Road Vehicles & International Transportation Electrification Conference (ESARS-ITEC), Venice, 29-31 March 2023, 1-6. https://doi.org/10.1109/ESARS-ITEC57127.2023.10114899
Said Jneid, M. and Harth, P. (2023) Integrated Torque Vectoring Control Using Vehicle Yaw Rate and Sideslip Angle for Improving Steering and Stability of All off-Wheel-Motor Drive Electric Vehicles, Forthcoming..
Joa, E., Yi, K., Sohn, K. and Bae, H. (2018) Four-Wheel Independent Brake Control to Limit Tire Slip under Unknown Road Conditions. Control Engineering Practice, 76, 79-95. https://doi.org/10.1016/j.conengprac.2018.04.001
Hartani, K., Khalfaoui, M., Merah, A. and Aouadj, N. (2018) A Robust Wheel Slip Control Design with Radius Dynamics Observer for EV. The SAE International Journal of Vehicle Dynamics, Stability, and NVH, 2, 135-146. https://doi.org/10.4271/10-02-02-0009
Choi, S.B. (2008) Antilock Brake System with a Continuous Wheel Slip Control to Maximize the Braking Performance and the Ride Quality. IEEE Transactions on Control Systems Technology, 16, 996-1003. https://doi.org/10.1109/TCST.2007.916308
Montani, M., Vitaliti, D., Capitani, R. and Annicchiarico, C. (2020) Performance Review of Three Car Integrated ABS Types: Development of a Tire Independent Wheel Speed Control. Energies, 13, Article 6183. https://doi.org/10.3390/en13236183
Challa, A., Ramakrushnan, K., Gaurkar, P.V., Subramanian, S.C., Vivekanandan, G. and Sivaram, S. (2021) A 3-Phase Combined Wheel Slip and Acceleration Threshold Algorithm for Anti-Lock Braking in Heavy Commercial Road Vehicles. Vehicle System Dynamics, 60, 2312-2333. https://doi.org/10.1080/00423114.2021.1903048
Patil, A., Nissimagoudar, P., Naik, A., Lingadhal, A.C., Mirashi, J.V. and Ingale, K.R. (2021) Optimization of Braking-Torque in Anti-Lock Braking System Using Perturb & Observe Technique. 2021 International Conference on Smart Generation Computing, Communication and Networking (SMART GENCON), Pune, 29-30 October 2021, 1-6. https://doi.org/10.1109/SMARTGENCON51891.2021.9645850
Harly, M. (2020) Modeling of Hydraulic ABS Plant and Its Control by Using Fuzzy Mamdani with Adaptive Slip Frequency to Improve Stopping Distance and Steering Ability. Journal of Physics: Conference Series, 1700, Article ID: 012044. https://doi.org/10.1088/1742-6596/1700/1/012044
Zhang, H., Liang, H., Tao, X., Ding, Y., Yu, B. and Bai, R. (2021) Driving Force Distribution and Control for Maneuverability and Stability of a 6WD Skid-Steering EUGV with Independent Drive Motors. Applied Sciences, 11, Article 961. https://doi.org/10.3390/app11030961
Chen, X., Wei, L., Wang, X., Li, L., Wu, Q. and Xiao, L. (2021) Hierarchical Cooperative Control of Anti-Lock Braking and Energy Regeneration for Electromechanical Brake-by-Wire System. Mechanical Systems and Signal Processing, 159, Article ID: 107796. https://doi.org/10.1016/j.ymssp.2021.107796
Koylu, H. and Tural, E. (2021) Experimental Study on Braking and Stability Performance during Low Speed Braking with ABS under Critical Road Conditions. Engineering Science and Technology, an International Journal, 24, 1224-1238. https://doi.org/10.1016/j.jestch.2021.02.001
You, S., Gil, J. and Kim, W. (2021) Fixed-Time Slip Control with Extended-State Observer Using Only Wheel Speed for Anti-Lock Braking Systems of Electric Vehicles. IEEE Transactions on Intelligent Transportation Systems, 23, 6368-6378. https://doi.org/10.1109/TITS.2021.3055980
Wang, B., Huang, X., Wang, J., Guo, X. and Zhu, X. (2015) A Robust Wheel Slip Ratio Control Design Combining Hydraulic and Regenerative Braking Systems for in-Wheel-Motors-Driven Electric Vehicles. Journal of the Franklin Institute, 352, 577-602. https://doi.org/10.1016/j.jfranklin.2014.06.004
Burton, D., Delaney, A., Newstead, S., Logan, D. and Fildes, B. (2004) Evaluation of Anti-Lock Braking Systems Effectiveness. Research Report 00/04.
Kim, J., Kwon, B., Park, Y., Cho, H.J. and Yi, K. (2021) A Control Strategy for Efficient Slip Ratio Regulation of a Pneumatic Brake System for Commercial Vehicles. Proceedings of the Institution of Mechanical Engineers, Part D: Journal of Automobile Engineering, 236, 1546-1567. https://doi.org/10.1177/09544070211038466
Yuan, Y., Zhang, J., Li, Y. and Lv, C. (2017) Regenerative Brake-by-Wire System Development and Hardware-in-Loop Test for Autonomous Electrified Vehicle. SAE Technical Papers 2017-01-0401. https://doi.org/10.4271/2017-01-0401
Said Jneid, M., Harth, P. and Ficzere, P. (2020) In-Wheel-Motor Electric Vehicles and Their Associated Drivetrains. International Journal for Traffic and Transport Engineering, 10, 415-431. https://doi.org/10.7708/ijtte.2020.10(4).01
Fan, L.K., et al. (2022) A GA-Based Online Real-Time Optimized Energy maNagement Strategy for Plug-in Hybrid Electric Vehicles. Energy, 241, Article ID: 122811. https://doi.org/10.1016/j.energy.2021.122811
Amato, G. and Marino, R. (2021) Reconfigurable Slip Vectoring Control in Four in-Wheel Drive Electric Vehicles. Actuators, 10, Article 157. https://doi.org/10.3390/act10070157
Favilli, T., Delogu, M., Pugi, L. and Berzi, L. (2021) Functional Safety and Reliability for Innovative Vehicle Braking System and Integration with Electric Traction Units. IOP Publishing, Bristol, p. 012020.
Zhang, L., Pang, Z., Wang, S., Zhang, S. and Yuan, X. (2020) Electromechanical Composite Brake Control for Two in-Wheel Motors Drive Electric Vehicle with Single Motor Failure. Proceedings of the Institution of Mechanical Engineers, Part D: Journal of Automobile Engineering, 234, 1057-1074. https://doi.org/10.1177/0954407019864229
Oleksowicz, S.A., et al. (2013) Regenerative Braking Strategies, Vehicle Safety and Stability Control Systems: Critical Use-Case Proposals. Vehicle System Dynamics, 51, 684-699. https://doi.org/10.1080/00423114.2013.767462
Vodovozov, V., Raud, Z., Petlenkov, E. and Babu, S. (2021) Review on Braking Energy Management in Electric Vehicles. Energies, 14, Article 4477. https://doi.org/10.3390/en14154477
Sakai, A., Miyazaki, T., Okano, T., Nimura, K. and Nakata, D. (2014) Regenerative Braking Systems. In: Crolla, D., Foster, D.G., Kobayashi, T. and Vaughan, N., Eds., Encyclopedia of Automotive Engineering, John Wiley & Sons, New York, 1-15. https://doi.org/10.1002/9781118354179.auto053
Tiwari, A. and Teja, A.V.R. (2021) Anti Lock Regenerative Braking Scheme for BLDC-Motor Driven Electric Vehicles. 2021 IEEE 30th International Symposium on Industrial Electronics (ISIE), Kyoto, 20-23 June 2021, 1-6. https://doi.org/10.1109/ISIE45552.2021.9576436
von Albrichsfeld, C. and Karner, J. (2009) Brake System for Hybrid and Electric Vehicles. SAE Technical Paper 2009-01-1217.
Yang, C., Liu, K., Jiao, X., Wang, W., Chen, R. and You, S. (2022) An Adaptive Firework Algorithm Optimization-Based Intelligent Energy Management Strategy for Plug-in Hybrid Electric Vehicles. Energy, 239, Article ID: 122120. https://doi.org/10.1016/j.energy.2021.122120
Zhuo, G., Yu, F. and Ren, Y. (2015) Study on the Braking Torque Allocation of the ABS Based on the Frequency of the Electro-Hydraulic Brake. SAE Technical Papers 2015-01-2703. https://doi.org/10.4271/2015-01-2703
Ivanov, V. and Savitski, D. (2015) Systematization of Integrated Motion Control of Ground Vehicles. IEEE Access, 3, 2080-2099. https://doi.org/10.1109/ACCESS.2015.2496108
Zhang, J., Kong, D., Chen, L. and Chen, X. (2012) Optimization of Control Strategy for Regenerative Braking of an Electrified Bus Equipped with an Anti-Lock Braking System. Proceedings of the Institution of Mechanical Engineers, Part D: Journal of Automobile Engineering, 226, 494-506. https://doi.org/10.1177/0954407011422463
Lv, C., Zhang, J., Li, Y. and Yuan, Y. (2015) Novel Control Algorithm of Braking Energy Regeneration System for an Electric Vehicle during Safety-Critical Driving Maneuvers. Energy Conversion and Management, 106, 520-529. https://doi.org/10.1016/j.enconman.2015.09.062
Mei, P., Yang, S., Xu, B. and Sun, K. (2021) A Fuzzy Sliding-Mode Control for Regenerative Braking System of Electric Vehicle. 2021 7th International Conference on Control, Automation and Robotics (ICCAR), Singapore, 23-26 April 2021, 397-401. https://doi.org/10.1109/ICCAR52225.2021.9463463
Ahangarnejad, A.H., Radmehr, A. and Ahmadian, M. (2020) A Review of Vehicle Active Safety Control Methods: From Antilock Brakes to Semiautonomy. Journal of Vibration and Control, 27, 1683-1712. https://doi.org/10.1177/1077546320948656
Said Jneid, M., Zöldy, M. and Harth, P. (2023) Sensorless Optimal Control of Electronic Wedge Brake Based on Dynamic Model and Kalman Filter State Multiple-Estimation. Proceedings of the Institution of Mechanical Engineers, Part D: Journal of Automobile Engineering. https://doi.org/10.1177/09544070231168168
Said Jneid, M. and Joukhadar, A. (2019) LQR-Based Control of a Single Motor Electronic Wedge Brake EWB for Automotive Brake-by-Wire System. Soft Computing and Electrical Engineering, 1, 12-35.
Shyrokau, B., Wang, D., Heidrich, L. and Höpping, K. (2013) Analysis of Subsystems Coordination for Electric Vehicle during Straight-Line Braking and Brake-in-Turn. 2013 IEEE Symposium on Computational Intelligence for Engineering Solutions (CIES), Singapore, 16-19 April 2013, 61-67.
Zhang, L., Zhang, Z., Wang, Z., Deng, J. and Dorrell, D.G. (2021) Chassis Coordinated Control for Full X-by-Wire Vehicles-A Review. Chinese Journal of Mechanical Engineering, 34, Article No. 42. https://doi.org/10.1186/s10033-021-00555-6
Jordanoska, V., Danev, D. and Changoski, V. (2021) Evaluating Coordinated Cooperative Control of Three Active Car Systems Using Fuzzy-Logic. IOP Publishing, Bristol, 1190, p. 012029.
Aly, A.A., Zeidan, E.S., Hamed, A. and Salem, F. (2011) An Antilock-Braking Systems (ABS) Control: A Technical Review. Intelligent Control and Automation, 2, 186-195. https://doi.org/10.4236/ica.2011.23023
Subramaniyam, K.V. and Subramanian, S.C. (2021) Electrified Vehicle Wheel Slip Control Using Responsiveness of Regenerative Braking. IEEE Transactions on Vehicular Technology, 70, 3208-3217. https://doi.org/10.1109/TVT.2021.3066095
Tang, Q., Yang, Y., Luo, C., Yang, Z. and Fu, C. (2022) A Novel Electro-Hydraulic Compound Braking System Coordinated Control Strategy for a Four-Wheel-Drive Pure Electric Vehicle Driven by Dual Motors. Energy, 241, Article ID: 122750. https://doi.org/10.1016/j.energy.2021.122750
Zhao, W., Wu, G., Wang, C., Yu, L. and Li, Y. (2019) Energy Transfer and Utilization Efficiency of Regenerative Braking with Hybrid Energy Storage System. Journal of Power Sources, 427, 174-183. https://doi.org/10.1016/j.jpowsour.2019.04.083
Mei, P., Karimi, H.R., Yang, S., Xu, B. and Huang, C. (2021) An Adaptive Fuzzy Sliding-Mode Control for Regenerative Braking System of Electric Vehicles. Journal of Adaptive Control and Signal Processing, 36, 391-410. https://doi.org/10.1002/acs.3347
Vodovozov, V., Aksjonov, A., Petlenkov, E., Raud, Z. and Romero-Cadaval, E. (2021) Neural Network-Based Model Reference Control of Braking Electric Vehicles. Energies, 14, Article 2373. https://doi.org/10.3390/en14092373
Torinsson, J., Jonasson, M., Yang, D. and Jacobson, B. (2020) Energy Reduction by Power Loss Minimisation through Wheel Torque Allocation in Electric Vehicles: A Simulation-Based Approach. Vehicle System Dynamics, 60, 1488-1511. https://doi.org/10.1080/00423114.2020.1858121
Heydrich, M., et al. (2021) Integrated Braking Control for Electric Vehicles with in-Wheel Propulsion and Fully Decoupled Brake-by-Wire System. Vehicles, 3, 145-161. https://doi.org/10.3390/vehicles3020009
De Castro, R., Araújo, R.E., Tanelli, M., Savaresi, S.M. and Freitas, D. (2012) Torque blending and Wheel Slip Control in EVs with in-Wheel Motors. Vehicle System Dynamics, 50, 71-94. https://doi.org/10.1080/00423114.2012.666357
Han, J. and Park, Y. (2014) Cooperative Regenerative Braking Control for Front-Wheel-Drive Hybrid Electric Vehicle Based on Adaptive Regenerative Brake Torque Optimization Using Under-Steer Index. International Journal of Automotive Technology, 15, 989-1000. https://doi.org/10.1007/s12239-014-0104-9
Ding, S., Liu, L. and Zheng, W.X. (2017) Sliding Mode Direct Yaw-Moment Control Design for in-Wheel Electric Vehicles. IEEE Transactions on Industrial Electronics, 64, 6752-6762. https://doi.org/10.1109/TIE.2017.2682024
Pacejka, H.B. (2012) Tire and Vehicle Dynamics. Butterworth-Heinemann, Oxford.
Nam, K. (2015) Application of Novel Lateral Tire Force Sensors to Vehicle Parameter Estimation of Electric Vehicles. Sensors, 15, 28385-28401. https://doi.org/10.3390/s151128385
Bisht, V., Saravanakumar, D., Sakthivel, G. and Sivakumar, R. (2021) Yaw Moment Compensation by Actuator-Based Control of Brake System in Automobiles. Journal of Physics: Conference Series, 1969, Article ID: 012063.
Su, L., Wang, Z. and Chen, C. (2022) Torque Vectoring Control System for Distributed Drive Electric Bus under Complicated Driving Conditions. Assembly Automation, 42, 1-18. https://doi.org/10.1108/AA-12-2020-0194
Miranda, M.H.R., Silva, F.L., Lourenço, M.A.M., Eckert, J.J. and Silva, L.C.A. (2022) Electric Vehicle Powertrain and Fuzzy Controller Optimization Using a Planar Dynamics Simulation Based on a Real-World Driving Cycle. Energy, 238, Article ID: 121979. https://doi.org/10.1016/j.energy.2021.121979
Boerboom, M. (2012) Electric Vehicle Blended Braking Maximizing Energy Recovery While Maintaining Vehicle Stability and Manouverability. Master’s Thesis, Chalmers University of Technology, Göteborg.
Yeo, H., Koo, C., Jung, W., Kim, D. and Cheon, J.S. (2011) Development of Smart Booster Brake Systems for Regenerative Brake Cooperative Control. SAE Technical Pape 2011-01-2356. https://doi.org/10.4271/2011-01-2356
Yin, G., Wang, S. and Jin, X. (2013) Optimal Slip Ratio Based Fuzzy Control of Acceleration Slip Regulation for Four-Wheel Independent Driving Electric Vehicles. Mathematical Problems in Engineering, 2013, Article ID: 410864. https://doi.org/10.1155/2013/410864
Singh, K.B., Arat, M.A. and Taheri, S. (2013) An Intelligent Tire Based Tire-Road Friction Estimation Technique and Adaptive Wheel Slip Controller for Antilock Brake System. The Journal of Dynamic Systems, Measurement, and Control, 135, Article ID: 031002. https://doi.org/10.1115/1.4007704
Qiu, Y., Liang, X. and Dai, Z. (2015) Backstepping Dynamic Surface Control for an Anti-Skid Braking System. Control Engineering Practice, 42, 140-152. https://doi.org/10.1016/j.conengprac.2015.05.013
Reif, K. (2014) Brakes, Brake Control and Driver Assistance Systems Function, Regulation and Components Bosch Professional Automotive Information. Springer, Berlin.
Boisvert, M. and Micheau, P. (2016) Estimators of Wheel Slip for Electric vehIcles Using Torque and Encoder Measurements. Mechanical Systems and Signal Processing, 76-77, 665-676. https://doi.org/10.1016/j.ymssp.2016.02.017
Mirzaeinejad, H. and Mirzaei, M. (2010) A Novel Method for Non-Linear Control of Wheel Slip in Anti-Lock Braking Systems. Control Engineering Practice, 18, 918-926. https://doi.org/10.1016/j.conengprac.2010.03.015
Chowdhri, N., Ferranti, L., Iribarren, F.S. and Shyrokau, B. (2021) Integrated Non-Linear Model Predictive Control for Automated Driving. Control Engineering Practice, 106, Article ID: 104654. https://doi.org/10.1016/j.conengprac.2020.104654