Chemical Characterization of Tomato Industry Wastewater, Florida, United States
- 1 Soil and Water Quality Laboratory, Gulf Coast Research and Education Center, University of Florida, Wimauma, Florida, USA
- 2 Soil and Water Quality Laboratory, Gulf Coast Research and Education Center, University of Florida, Wimauma, Florida, USA
- 3 Soil and Water Quality Laboratory, Gulf Coast Research and Education Center, University of Florida, Wimauma, Florida, USA
Abstract
Tomato packers often struggle to find ways to reuse the large volumes of wastewater generated during the tomato cleaning and sanitizing processes due to high transportation costs for off-site disposal and strict surface water discharge regulations in Florida. Information about the composition of tomato packinghouse wastewater and the likely sources of major wastewater constituents might provide insights to develop environmentally sustainable practices for wastewater reuse. The objective of this study was to characterize the chemical composition of wastewater generated in tomato packinghouses. The wastewater samples were collected for 6 to 8 hours from dump tanks of two representative packinghouses at 30 minute intervals after start-up of packing operations during May-June 2009. Results showed that wastewater had high electrical conductivity (1.3 - 2.8 dS·m –1 ) and chloride (255 - 1125 mg·L –1 ) due to the use of chlorine as a sanitizer in the packinghouses. Concentrations of total phosphorus (P, 2.8 - 5.7 mg·L –1 ) and copper (Cu, 1.9 - 2.2 mg·L –1 ) in wastewater were elevated due to tomato cleaning and sanitizing. To reduce P and Cu concentrations, treatment or blending of wastewater may be needed before discharging wastewater to surface waters. Concentrations of P, potassium, calcium, magnesium, zinc, iron, and manganese were much higher in packinghouse 1 as compared to packinghouse 2 wastewater, probably due to the greater contact time of tomatoes with the dump tank water. Whereas concentrations of Cu were similar in both packinghouses wastewater. Greater concentrations of chemical constituents in the wastewater suggest that residues of pesticides, insecticides, and/or foliar-applied micronutrients on tomatoes may be the likely external sources of most constituents (especially P, Cu, and Zn) in wastewater.
- FDEP, “General Facts and Statistics about Wastewater in Florida,” 12 June 2011. http://www.dep.state.fl.us/water/wastewater/facts.htm
- G. A. O’Connor, H. A. Elliott and R.K. Bastian, “Degraded Water Reuse: An Overview,” Journal of Environmental Quality, Vol. 37, Suppl. 5, 2008, pp. S157- S168.
- California League of Food Processing, “Manual of Good Practice for Land Application of Food Processing/Rinse Water,” Davis, CA, 2007.
- A. A. Szogi and M. B. Vanotti, “Removal of Phosphorus from Livestock Effluents,” Journal of Environmental Quality, Vol. 38, No. 2, 2009, pp. 576-586. doi:10.2134/jeq2007.0641
- G. Firfilionis, et al., “The Removal of Trace Metals at the Wastewater Treatment Plant of Psyttalia,” Mediterranean Marine Science, Vol. 5/1, 2004, pp. 71-81.
- Florida Tomato Committee, “Options for Utilization of Tomato Packinghouse Solid Waste and Water,” In: Critical Issues in Tomato Production in Florida—A Special Research Report, Florida Tomato Committee and University of Florida/IFAS, 2007.
- Florida Administrative Weekly, “Florida Administrative Weekly and Florida Administrative Code 62-302.530,” 2006.
- FDEP, “Water Rules by Program Area: Wastewater,” 12 June 2011, Cited 16 August 2010. http://www.dep.state.fl.us/water/rulesprog.htm#ww
- K. L. Rule, et al., “Diffuse Sources of Heavy Metals Entering an Urban Wastewater Catchment,” Chemosphere, Vol. 63, No. 1, 2006, pp. 64-72. doi:10.1016/j.chemosphere.2005.07.052
- P. Crawford, et al., “Corrosion of a Stainless Steel Chemical Hood,” Engineering Failure Analysis, Vol. 5, No. 1, 1998, pp. 53-56. doi:10.1016/S1350-6307(97)00032-0
- T. Eliades, et al., “Characterization and Cytotoxicity of Ions Released from Stainless Steel and Nickel-Titanium Orthodontic Alloys,” American Journal of Orthodontics and Dentofacial Orthopedics, Vol. 125, No. 1, 2004, pp. 24-29. doi:10.1016/j.ajodo.2003.09.009
- H. F. Bohner and R. L. Bradley, “Corrosivity of Chlorine Dioxide Used as Sanitizer in Ultrafiltration Systems,” Journal of Dairy Science, Vol. 74, No. 10, 1991, pp. 3348-3352. doi:10.3168/jds.S0022-0302(91)78523-8
- S. M. Olson and E. Simonne, “Vegetable Production Handbook for Florida,” IFAS/Extension, University of Florida, 2009, pp. 291-313.
- J. A. Bartz, S. A. Sargent and M. Mahovic, “Guide to Identifying and Controlling Post Harvest Tomato Diseases in Florida,” IFAS/extension HS 866, University of Florida, 2009.