This paper presents the effect of fly ash grain-size fractions on Portland-fly ash cement hydration and its properties. Siliceous fly ashes of size fraction of 0 - 16 and 16 - 32 μm, separated from initial fly ash samples from 1 st , 2 nd and 3 rd hopper in ESP system, were analysed. Cement hydration was investigated by determination of hydration heat and con tent of Ca(OH) 2 and C 3 S in cement samples. Water to cement ratio and initial setting time of cement pastes as well as compressive strength and microstructure of cement mortars were also analyzed. Results showed that the same amount of the same size ash fraction can give cement of lower or higher early strength and its lower or higher increase with time. Incorporation of 20 wt% of ash fraction of 0 - 16 μm can produce Portland-fly ash cement CEM II/A-V of strength class 42.5R (from 2 nd hopper) or 52.5N (from 3 rd hopper). Cement containing 40 wt% of ash fraction of 0 - 16 μm from 2 nd and 3 rd hopper can be classified as pozzolanic cements CEM IV/A-V of strength class 42.5 and normal or rapid early strength, respectively. Different development of strength of cement with addition of the same size ash frac tion separated from the initial ash sample from the next hopper in ESP system is connected with higher depolymeriza tion degree of SiO 4 units in ash glass, resulting from the greater amount of AlO 4 units replacing SiO 4 units. Ash fraction of 16 - 32 μm shows lower depolymerisation of glass network and as a consequence lower hydration degree of C 3 S to portlandite and calcium silicate hydrates (C-S-H).
F. Massazza, “Pozzolana and Pozzolanic Cements,” In: P. Hewlett, Ed., Lea’s Chemistry of Cement and Concrete, Arnold, London, 1998, pp. 471-631.
E. Tkaczewska, “Influence of Physical and Chemical Properties of Siliceous Fly Ashes on Cement Hydration Process,” Ph.D. Thesis, AGH University of Science and Technology, Krakow, 2007.
F. H. Hubbard, R. K. Dhir and M. S. Ellis, “Pulverized Fuel Ash for Concrete: Compositional Characterisation of United Kingdom PFA,” Cement and Concrete Research, Vol. 15, No. 1, 1985, pp. 185-198. doi:10.1016/0008-8846(85)90025-0
J. Malolepszy and E. Tkaczewska, “Effect of Size Fraction of Fly Ashes on Their Pozzolanic Properties,” Proceedings of the 5th Conference of Polish Ceramic Society, Vol. 91, No. 2, 2005, pp. 1143-1150.
E. Tkaczewska and J. Malolepszy, “Hydration of Coal Biomass Fly Ash Cement,” Construction and Building Materials, Vol. 23, No. 7, 2009, pp. 2694-2700. doi:10.1016/j.conbuildmat.2008.12.018
S. Antiohos and S. Tsimas, “Incestigating the Role of Active Silica on the Hydration Mechanisms of High Calcium Fly Ash/Cement Systems,” Cement and Concrete Composites, Vol. 27, No. 2, 2005, pp. 171-181. doi:10.1016/j.cemconcomp.2004.02.004
S. H. Lee, E. Sakai, M. Diamon and W. K. Bang, “Characterization of Fly Ash Directly Collected from Electro static Precipitator,” Cement and Concrete Research, Vol. 29, No. 11, 1999, pp. 1791-1797. doi:10.1016/S0008-8846(99)00169-6
Ch. Jaturapitakkul, K. Kiattikomol and S. Songpiriyakij, “A Study of Strength Activity Index of Ground Coarse Fly Ash with Portland Cement,” Science Asia, Vol. 25, 1999, pp. 223-229. doi:10.2306/scienceasia1513-1874.1999.25.223
J. Malolepszy and E. Tkaczewska, “Effect of Fly Ash Fineness on the Fly Ash Cement Hydration and Proper ties,” Cement Lime Concrete, Vol. XII/LXXIV, No. 6, 2007, pp. 296-302.
S. H. Lee, H. J. Kim, E. Sakai and M. Daimon, “Effect of Particle Size Distribution of Fly Ash-Cement System on the Fluidity of Cement Pastes,” Cement and Concrete Research, Vol. 33, No. 5, 2003, pp. 763-768. doi:10.1016/S0008-8846(02)01054-2
M. C. Mills, “The Influence of Structure on the Physico Chemical Properties of Slags,” ISIJ International, Vol. 33, No. 1, 1993, pp. 148-155. doi:10.2355/isijinternational.33.148
E. Tkaczewska and J. Malolepszy, “The Properties of Glass in Siliceous Fly Ash,” Cement Lime Concrete, Vol. XIV/LXXVI, No. 3, 2009, pp. 148-153.
W. Bumrongjaroen, S. Swatekititham, R. A. Livingston and J. Schweitzer, “Synthetic Glass Models for Investigating Fly Ash Reactivity,” Proceedings of the 3rd International Conference on the Use of Fly Ash, Silica Fume, Slag, and Natural Pozzolans in Concrete, Warsaw, 2007, pp. 227-242.
E. Tkaczewska and M. Sitarz, “Effect of Chemical Com position and Structure of Glass in Siliceous Fly Ashes on Their Pozzolanic Activity,” Proceedings of the 6th Conference on Material Problems in Civil Engineering MATBUD’2011, Krakow, 2011, pp. 411-418.
E. Tkaczewska and M. Sitarz, “The Effect of Glass Structure on the Pozzolanic Activity of Siliceous Fly Ashes,” Physics and Chemistry of Glasses—European Journal of Glass Science and Technology Part B, Vol. 54, No. 2, 2013, pp. 89-94.
J. Dereń, J. Haber and R. Pampuch, “Solid State Chemis try,” Polish Scientific Publishers PWN, Warsaw, 1979.
E. Gorlich, “Chemistry of Silicates,” Polish Geological Institute, Warsaw, 1957.
J. Malolepszy and E. Tkaczewska, “Effect of Fraction Size of Siliceous Fly Ashes on Hydration and Properties of Cement,” Proceedings of the 5th Conference on Material Problems in Civil Engineering MATBUD’2007, Krakow, 2007, pp. 331-339.
W. Nocuń-Wczelik, “Heat Evolution in Hydrated Cemen titious Systems Admixtured with Fly Ash,” Journal of Thermal Analysis and Calorimetry, Vol. 65, No. 2, 2001, pp. 613-619. doi:10.1023/A:1017970228316
K. Ogawa, H. Uchikawa, K. Takemoto and I. Yasui, “The Mechanism of the Hydration in the System C3S—Pozzolana,” Cement and Concrete Research, Vol. 10, No. 5, 1980, pp. 683-696. doi:10.1016/0008-8846(80)90032-0
E. Tkaczewska, “Properties of Cement Containing Various Size Fractions of Siliceous Fly Ashes,” Roads and Bridges, Vol. 4, No. 4, 2008, pp. 47-80.
E. Tkaczewska and J. Malolepszy, “Studies on the Mineralogical Composition and Structure of Glass of Siliceous Fly Ashes,” Proceedings of the 54th Conference “The Scientific Research Problems of Building”, Vol. 5, 2008, pp. 411-418.
E. Sakai, S. Miyahara, S. Ohsawa, S. H. Lee and M. Daimon, “Hydration of Fly Ash Cement,” Cement and Concrete Research, Vol. 35, No. 6, 2005, pp. 1135-1140. doi:10.1016/j.cemconres.2004.09.008
M. P. De Luxán, M. I. Sánchez de Rojas and M. Frías, “Investigation on the Fly Ash—Calcium Hydroxide Re actions,” Cement and Concrete Research, Vol. 19, No. 1, 1989, pp. 69-80. doi:10.1016/0008-8846(89)90067-7
K. Takemoto and H. Uchikawa, “Hydration of Pozzolanic Cement,” Proceedings of the 7th International Congress on the Chemistry of Cement, Vol. 1, Sub-Theme IV-2 1980.
M. Sitarz, “The Structure of Simple Silicate Glasses in the Light of Middle Infrared Spectroscopy Studies,” Journal of Non-Crystalline Solids, Vol. 357, No. 6, 2011, pp. 1603-1608. doi:10.1016/j.jnoncrysol.2011.01.007
M. Sitarz, M. Handke and W. Mozgawa, “Identification of Silicooxygen Rings in SiO2 Based on IR Spectra,” Spectrochimica Acta Part A, Vol. 56, No. 9, 2000, pp. 1819-1826. doi:10.1016/S1386-1425(00)00241-9
P. Tarte, “Infrared Spectra of Inorganic Aluminates and Characteristic Vibrational Frequencies of AlO4 Tetrahedra and Also Octahedral,” Spectrochimica Acta A, Vol. 23, No. 7, 1967, pp. 2127-2143. doi:10.1016/0584-8539(67)80100-4
M. Taylor and G. E. Brown, “Structure of Mineral Glasses. II. The SiO2-NaAlSiO4 Join,” Geochimica et Cosmochimica Acta, Vol. 43, No. 9, 1979, pp. 1467-1473. doi:10.1016/0016-7037(79)90141-8
B.O. Mysen, D. Virgo and I. Kushiro, “The Structural Role of Aluminum in Silicate Melts—A Raman-Spectroscopic Study at 1-Atmosphere,” American Mineralogist, Vol. 66, No. 7-8, 1981, pp. 678-701.
S. Diamond, “The Microstructures of Cement Paste in Concrete,” Proceedings of the 8th International Congress on the Chemistry of Cement, Rio de Janeiro, 1986, pp. 122-147.