Development and Installation of High Pressure Boilers for Co-Generation Plant in Sugar Industries
- 1 nstitute of Sugar Technology, G.U.P.G. Center, Bidar, India
- 2 Department of Materials Science, Gulbarga University, Gulbarga, Karnataka, India
Abstract
The sugar cane containing minimum 30% fiber was referred as bagasse and used the generation of power required for the operation of sugar mill. The bagasse is fired in the boiler for producing steam at high pressure, which is extracted through various single high capacity turbines and used in the process. The installation of high pressure boilers and high pressure turbo-generators has provision for the operation of co-generation plant during the off-season also that enhances the power generation from 9MW to 23MW. The annual monetary benefits achieved are Rs. 204.13 million and this was based on cost of power sold to the grid @ Rs 2.548 per unit, sugar season of 219 days and off season of 52 days. This required an investment of Rs 820.6 million. The investment had an attractive simple payback period of 48 months.
- P. S. Sankarnaraynan, J. G. Evans and C. Dampdaran, “Energy Efficiency in the Sugar Plant Steam and Power Generation,” Avant-Garde, Engineers and Consultants Private Limited, Porur ,Vol. 1, 2000, pp. 1-6.
- A. Ataei, “Modification of Co-Generation Plant in a Sugar Cane Factory for Reduction of Power Deficit,” Research Journal of Environmental Science, Vol. 3, 2009, pp. 619-630.
- L. Lacrosse and S. K. Shakya, “Clean and Efficient Biomass Cogeneration Technology in Asean,” Power-Gen Asia Conference and Exhibition, 2004, pp. 5-7.
- C. Damodaran, N. Thirumoorthy and P. Parthasarthy, “Energy Audit in Sugar Industry,” Avant-Garde, En- gineers and Consultants Private Limited, Porur ,Vol. 1, 2008, pp. 1-6.
- R. H. Weed and M. L. Wisdom, “Condensate Consider- ations in the Development of High Pressure Co-Gene- ration Facilities” BetzDearborn Inc., Trevose, 1998.
- Idehara, “Indian Sugar Factories Cogeneration Design Review,” Winrock International, Vol. 1, 2004, pp. 1-12.
- E. Worrell, R. van Berkel, F. Q. Zhou, C. Menke, R. Schaeler and R. O. Williams “Technology Transfer of Energy Science Technologies in Industry,” A Review of Trends and Policy Issues, Energy Policy, Vol. 29, 2001, pp. 29-43.
- E. D. Larson and R. H. Williams and M. R. L.V. Leal, “Energy for Sustainable Development,” Vol. 1, 2001, p. 11.
- “Consensus on Operating Practices for the Control of Feed Water and Boiler Water Chemistry in Modern Industrial Boilers,” ASME, Vol. 1, 1998.
- S. Dunn, “Re: Condensate Contamination Monitors,” International Communication, BetzDearborn, 1997.
- V. Kirubakaran., V. Sivaramakrishnan, R. Nalini, T. Sekar, M. Premalatha and P. Subramanian, “A Review on Gasification of Biomass,” Renew Sustain Energy Review, Vol. 13, 2009, pp. 179-186.
- M. Asadi, “Beet-Sugar Hand Book,” First Edition, J. Wiley and Sons, Inc., Vol. 1, 2007.
- B. W. Lamb and R. W. Bilger, “The Combustion of a Wet Cellulosic Fuel Bed,” Sugar Technology Review, Vol. 4, No. 2, 1977, pp. 89-130.